Check every oil change (Oil change interval for the 6.0L Power
Stroke engine is 10,000 miles [16,000 km]; (refer to the
Caterpillar and Cummins service manuals for instructions and
information)
Engine system Check the engine cooling system -
hoses, clamps and protection*.
Inspect the drive belts.
Exhaust system Inspect the entire exhaust system
(including the inlet pipe(s),
muffler(s), outlet pipe(s), clamps and
fasteners) for holes, leakage,
breakage, corrosive damage and
separation from other components.
Adjust, service or replace with the
same or the equivalent part. (Also a
noise emission control service).
Suspension system Tighten the front and rear spring
U-bolts to the specified torque.
Driveline and rear axle
system
Lubricate the U-joints and the slip
yoke.
Brake system Lube the air brake foot control valve,
hinge and roller.
Inspect the drum brake linings
through the inspection holes.
Lubricate the brake camshafts (air
brakes only).
Lubricate the brake slack adjuster (air
brakes only).
Lubricate rear caliper slide rails.
Inspect the disc brake pads and the
piston boots (hydraulic brakes only).
Clutch system Lubricate the clutch release cross
shaft and all linkages.
Check the clutch fluid.
2006 F-650/750 (f67)
Supplement
USA (fus)
Scheduled Maintenance Guide
242
To Next Page
Loading...
Need help?
General
