Home
Fresenius Medical Care
Medical Equipment
2008K
Fresenius Medical Care 2008K Technical Manual
5
of 1
of 1 rating
216 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
FRESENIUS USA
2008K HEMODIALYSIS SYSTEM
TECHNICIAN’S
MANUAL
Part Number
490049 Rev A
FRESENIUS USA
2637 SHADELANDS DRIVE
WALNUT CREEK, CALIF. 94598
(925) 295-0200
(800) 227-2572
Copyright
2000 Fresenius USA, Inc.
2
Table of Contents
Fresenius Usa
2
Table of Contents
2
Specifications
3
General Warnings and Cautions
12
Hydraulic Description
17
Valve
18
Electronic Circuit Description
29
Module Description
35
Calibration and Installation Procedures
41
Calibration Procedures
46
1 Introduction
48
Test Equipment Needed
49
Operating Modes
50
Front Panel Controls
53
Measuring Fluid Volumes
55
Calibrate if Replaced
56
2 Service Mode Calibrations
57
Touch Screen Calibration
57
Hydraulic Calibration Procedures
58
Deaeration and Loading Pressure Calibration
59
Flow Pressure Calibration
61
Balance Chamber Volume Calibration
62
Acid (Concentrate) Pump Volume Calibration
64
Bicarbonate Pump Volume Calibration
66
Uf Pump Volume Calibration
68
Sensor Calibration Procedures
71
Arterial Pressure Calibration
72
Venous Pressure Calibration
77
Dialysate Pressure Calibration
80
Temperature Sensor Calibration
83
Post Temperature Sensor Calibration
85
Temperature Control Calibration
87
Temperature Control Calibration (Slow Flow Not Enabled)
87
Temperature Control Calibration (Slow Flow or Crrt)
90
Blood Leak Calibration
94
Conductivity Cells Calibration
96
Monitor Calibration Procedures
98
Set Clock
99
Voltage Detection Calibration
100
Arterial Pump Rate
103
Venous Pump Rate
104
3 Calibration Procedures Not Performed in Service Mode
105
Inlet Water Pressure Regulator Calibration
105
Level Detector Calibration
107
Blood Pump Calibration
109
Troubleshooting
132
Maintenance
156
Preventive Maintenance Procedures
161
1 Introduction
163
Test Equipment and Supplies Needed
163
Front Panel Controls
165
Measuring Fluid Volumes
167
2 Quarterly (1000 Hour) Preventive Maintenance
168
Filters and O-Rings
170
Diasafe Filter (if Applicable)
170
Check Valves
171
Uf Pump
172
Conductivity
175
Temperature
175
Alarm and Pressure Holding Tests
176
Labels and Mechanical Condition
179
3 Annual (4000 Hour) Preventive Maintenance
180
Filters, O-Rings and Check Valves
180
Diaphragm Pumps
180
Heater Element
180
High Voltage Ac Connections
181
Deaeration Motor Brushes
182
Inlet Water Pressure Regulator
183
Online Clearance Test (if Applicable)
184
Deaeration and Loading Pressure
187
Flow Relief Pressure
188
Conductivity
188
Temperature
188
Volt Hi lo Detect
189
Blood Leak and Dimness
189
Arterial, Venous and Transmembrane Pressure
190
Dialysate Flow
192
Heparin Pump
192
Blood Pump
194
Level Detector
195
Alarm and Pressure Holding Tests
197
Rinse Checks
197
Battery and Power Failure Alarm
198
Blood Pressure Module
198
Final Checks
200
4 Rebuilding the Diaphragm Pumps
201
Rebuilding the Ultrafiltration Pump
201
Rebuilding the Concentrate and Bicarbonate Pumps
204
Testing Concentrate and Bicarbonate Pumps
206
Preventive Maintenance Checklist Quarterly/1000 Hour
209
Preventive Maintenance Checklist Annual/4000 Hour
211
Other manuals for Fresenius Medical Care 2008K
Operator's Manual
240 pages
Maintenance
72 pages
Calibration Manual
84 pages
Operator's Guide
6 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Fresenius Medical Care 2008K and is the answer not in the manual?
Ask a question
Fresenius Medical Care 2008K Specifications
General
Brand
Fresenius Medical Care
Model
2008K
Category
Medical Equipment
Language
English
Related product manuals
Fresenius Medical Care 2008T
768 pages
Fresenius Medical Care 2008K2
66 pages
2008T BlueStar
11 pages
Fresenius Medical Care 5008
328 pages
Fresenius Medical Care 4008 S
408 pages
Fresenius Medical Care 4008 E
595 pages
Fresenius Medical Care 4008 H
595 pages
Fresenius Medical Care Liberty
29 pages
bibag V2.0
40 pages
T200 Series
11 pages
GranuFlo 450368-03
67 pages
GranuFlo Dissolution Unit II
58 pages
Need help?
General
To Next Page
