Name: Kubota RTV900
Brand: Kubota
Rating: 5 (1 reviews)

To Next Page

Code No. K7581-7121-5

OPERATOR'S MANUAL

UTILITY VEHICLE

KUBOTA Corporation 2009

PRINTED IN U.S.A.

READ AND SAVE THIS MANUAL

Table of Contents5
Safe Operation21
Servicing of Vehicle21
Specifications22
Specification Table22
Traveling Speeds23
Vehicle Limitations24
Instrument Panel and Controls25
Location of Parts25
Pre-Operation Check29
Daily Check29
Operating the Engine30
Starting the Engine30
Cold Weather Starting33
Block Heater33
Stopping the Engine33
Warming up33
Warm-Up Transmission Oil in the Low Temperature Range33
Jump Starting34
Operating the Vehicle35
Operating New Vehicle35
Do Not Operate the Vehicle at Full Speed for the First 50 Hours35
Changing Lubricating Oil for New Vehicles35
Starting35
Seat Belt35
Head Light Switch36
Hazard Light Switch36
Turn Signal Light Switch36
Horn Button37
Work Light (Front)37
Work Light (Rear)37
Brake Pedal38
Range Gear Shift Lever38
4WD Lever39
Parking Brake Lever39
Speed Control Pedal39
Stopping40
Check During Driving40
Immediately Stop the Engine if40
Easy Checker(TM)40
Fuel Gauge41
Coolant Temperature Gauge41
Hourmeter41
Speedometer42
Parking42
Parking Brake Lever42
Accessory43
(1) 12V Electric Outlet43
Utility Box43
Operating Techniques43
Differential Lock43
Directions for Use of Power Steering44
Unfamiliar Terrain44
Driving in Reverse45
Driving in "4WD45
Turning the Vehicle46
Hills46
Traversing Hillsides47
Sliding and Skidding47
Driving through Water47
Operating Hand Throttle48
Stationary Hydraulic Outlet48
Cargo Bed49
General Caution49
Max. Cargo Load49
Cargo Bed Tailgate50
Raising and Lowering the Cargo Bed51
Hydraulic Outlet52
Hydraulic Outlet Lever52
Hydraulic Outlet Valve Coupler Connecting and Disconnecting53
Tires and Wheels54
Tires54
Inflation Pressure54
Tire Type and Use54
Wheels55
Towing and Transporting56
Rear Trailer Hitch56
Front Trailer Hitch56
Winch Mount Bracket57
Transporting Vehicle57
Maintenance58
Service Intervals58
Lubricants, Fuel and Coolant61
Periodic Service64
How to Open the Hood and Tilt the Seat64
Hood64
Operator's Seat64
How to Raise the Cargo Bed65
Raising and Lowering the Cargo Bed [If Equipped with Hydraulic Dump]65
Raising and Lowering the Cargo Bed [Without Hydraulic Dump]66
Jack-Up Point66
Front End66
Rear End66
Daily Check67
Walk Around Inspection67
Checking and Refueling67
Checking Engine Oil Level68
Checking Transmission Fluid Level68
Checking Power Steering Oil Tank Level69
Checking Hydraulic Lift Oil Tank Level69
Checking Hydraulic Auxiliary Tank Oil Level70
Cleaning Oil Cooler Net70
Checking Coolant Level71
Cleaning Radiator Screen71
Checking Brake Fluid Level72
Checking Brake Pedal72
Checking Parking Brake73
Checking Gauges, Meter and Easy Checker(TM)73
Checking Head Light, Turn Signal Light Etc73
Checking Seat Belt and ROPS73
Checking Joint Boot73
Checking Tire Inflation Pressure74
Checking Backup Beeper74
Every 50 Hours75
Greasing75
Oiling76
Checking Engine Start System76
Every 100 Hours77
Checking VHT Neutral Spring77
Checking VHT Pressure Release77
Checking Wheel Bolt Torque78
Cleaning Air Cleaner Primary Element79
Adjusting Alternator Belt Tension79
Checking Fuel Line and Fuel Filter80
Checking Battery Condition81
Adjusting Toe-In82
Cleaning Muffler83
Every 150 Hours84
Cleaning Air Cleaner Primary Element84
Every 200 Hours85
Adjusting Parking Brake85
Replacing Engine Oil Filter85
Changing Engine Oil86
Replacing Transmission Oil Filter [HST]87
Replacing Transmission Oil Filter [SUCTION]88
Changing Hydraulic Lift Oil89
Changing Hydraulic Auxiliary Tank Oil90
Checking Brake Pedal91
Checking Brake Hose and Pipe91
Checking Front Brake Case92
Checking Brake Light Switch92
Checking Radiator Hose and Clamp92
Checking Power Steering Line93
Changing Power Steering Oil94
Checking Intake Air Line95
Checking Hydraulic Auxiliary Oil Line95
Every 300 Hours96
Checking Tire96
Every 400 Hours96
Changing Knuckle Case Oil96
Changing Transmission Fluid96
Replacing Hydraulic Auxiliary Tank Oil Filter97
Changing Front Axle Case Oil98
Every 500 Hours99
Replacing Fuel Filter99
Every 800 Hours99
Adjusting Engine Valve Clearance99
Every 1500 Hours99
Checking Fuel Injection Nozzle Injection Pressure99
Every 3000 Hours99
Checking Injection Pump99
Every 1 Year99
Replacing Air Cleaner Primary Element and Secondary Element99
Anti-Freeze100
Replacing Radiator Hose (Water Pipes)101
Replacing Power Steering Hose101
Replacing Fuel Hose101
Replacing Engine Breather Hose101
Replacing Brake Master Cylinder (Inner Parts)101
Replacing Front Brake Seal101
Replacing Rear Brake Cylinder Seal101
Replacing Intake Air Line101
Replacing Remote Hydraulic Hose101
Every 4 Years101
Replacing Slow-Blow Fuses102
Replacing Light Bulb103
Cleaning Oil Cooler Net103
Storage104
Vehicle Storage104
Removing the Vehicle from Storage104
Troubleshooting105
Engine Troubleshooting105
Battery Troubleshooting106

Brand	Kubota
Model	RTV900
Category	Utility Vehicle
Language	English

Kubota RTV900 User Manual

Table of Contents

Questions and Answers:

Kubota RTV900 Specifications

Related product manuals