TROUBLESHOOTING
Occasionally, a valve will not perform as desired. Here
are some helpful tips for troubleshooting:
RATIO: Look for foreign matter in the adjustment
screws, flow controls or pallet seats. If a system is not
flushed completely at start-up, foreign particles may be
introduced into the system. Reset the flow rate and
readjust the syrup ratio.
BUZZING: Do not lubricate the plungers. If
contaminated, simply wash with hot water, dry and
reinstall.
LEAKS: Check for damaged or improperly fitted O-
rings. The slightest piece of hair, dust, etc., on the
sealing surface may contribute to a leak. When in
doubt, replace an O-ring. Be sure you have the correct
O-ring and fitting combination for the respective
mounting plate.
For further technical assistance, call Manitowoc
Beverage Equipment at 1-800-367-4233.
FLOMATIC
WARRANTY
GET STARTED HERE
No. Part No. Description
1 5007842 MTG BLOCK 0.380
2 505 SCREW 4-40X1
3 507-36-G DIFFUSER BLOCK 464
4 509 ORING 112
5 510 SCREW 4-40X5/8
6 511-04 SPRING COIL PALLET RETAINER
7 512-02-G ORIFICE CAP GP LFT BLK
8 513-02-G ORIFICE CAP GP RT BLK
9 515-30 PALLET BEARING PAD SET
10 515_02 PALLET HIGHFLOW
11 516-06 LEVER SANITARY SS (SSL)
12 516-07 EURO LEVER PL BLK
13 516-09 LEVER SANITARY MOLDED
14 516-10 AUTOFILL LEVER SENSOR
15 517-05 LEVER RETAINER ELEC LG
16 524-02 PIVOT PIN LONG
17 526 SHUTOFF PLUG
18 527 SEAL SHUTOFF
19 528 SEAL QUAD VLV STEM
20 530 BEARING PALLET
21 538-04 LATCH PIN
No. Part No. Description
22 543 O-RING (010)
23 551 ORING 012
24 553-00 SCREW #6 X 3/8
25 562-80 BODY 380Q
26 564 S-CLIP
27 565 SCREW 8X1/2
28 567 RETAINER SHUTOFF PLUG
29 568 RETAINER QUAD STEM SEAL
30 600-47-G FLOW CTRL BASE 464 #8
31 602-03 CYLINDER HF
32 602-03-G CYLINDER GP
33 603-03-G PISTON SYRUP GP
34 604-04-G PISTON SODA GP
35 605-02 SPRING FLOW CTRL HF SODA
36 607 SCR FLOW RATE ADJ M
37 608 ORING 017
38 609-02 NUT BRIX ADJ 464
39 610-04 RETAINER PLATE 6-32
40 643-00 FLOW RATE ADJ 464 GP
41 774-A36 SOL AUTOFIL SNGL AC
42 774-E36 SOL MSL SNGL YOKE AC
No. Part No. Description
43 774-P36 SOL PCTRL SNGL YOKE AC
44 817-04 HARNESS CPM
45 835 PC MODULE 4 CUP
46 1028 ADD-A-LEVER 464
47 1028-S ADD-A-LEVER 464 SO
48 1028-W ADD-A-LEVER 464 WTR
49 1601 COVER BASE
50 1602 COVER PL FRONT
51 1610 COVER GP FRONT PB
52 9774-1 SOLENOID ASSEMBLY
53 5011953 SCR 10-24X1-1/4 SELF TAP
54 5028273 ORING SLEEVE
55 5030418 SWITCH, PCTRL
56 5030419 SWITCH, MSL
57 5030421 SWITCH, AUTOFILL
58 5031015 KIT AC PCTRL CONV 464
59 5031018 KIT AC AUTOFILLCONV
60 020001284 SCR #8 X 5/8 PH HI-LO 18-8
61 020001750 464 NOZZLE ASSEM
COMPLETE VALVE ASSEMBLIES
- 464GPS361625 Push Button
- 464GPE361621 Sanitary Lever
- 464GPA361621 Autofil
- 464GPP361600 Portion Control
FLOMATIC 464-GP POST-MIX VALVE
QUICK GUIDE FOR INSTALLATION & MAINTENANCE
FLOMATIC 464-GP
POST-MIX VALVE
To Previous Page
Loading...
Need help?
General