Multiplex FreshBlender Instruction Sheet

Instruction Sheet
Subject: FreshBlender Caster Brake Retrofit
SCOPE: ALL MULTIPLEX FRESHBLENDER UNITS
1 of 3
 DocumentNumber:020008727 April14,2021
MULTIPLEX
645 PARK EAST BLVD SUITE 5, NEW ALBANY, IN 47150
844-724-CARE
WWW.MULTIPLEXBEVERAGE.COM
Refreshing the Experience
TwopeoplearerequiredtocompletethisCasterBrake
Retrofit.
TOOLS REQUIRED
• Clean5-gallonbucket
• FreshBlenderDoorKey
• Six(6)Boards,2”x4”boardscutto2’lengths(5cmx
10cmcutto61cmlengths)
• 14mmWrench
• 14mmSocketandDriverorCordlessImpactDrill
PARTS REQUIRED
• BlueLocTite
• 020008731CasterBrakeRetrofitKit(kitpartslisted
below)
PART NO. DESCRIPTION QTY
020008728 BrakeHardwareSet 2
020008727 Instructions 1
BrakeHardwareshownbelow(doesnotincludewheelfork):
NUT
BRAKE BRACKET
BRAKE PEDAL
WAVE WASHER
BOLT
n
Warning
NeverleaveunitunattendedduringCasterBrakeRetrofit.
n
Warning
Unitisheavy.DoNOTattempttoliftbyhand.
,
Caution
Do NOT use a pry bar, crowbar or other sharp ended
objecttoleverageunitup.Sharpobjectswilldamageunit
refrigerationsystem.
REMOVE OLD HARDWARE
1. Pullunit12”(31cm)awayfromwall.
2. Place5-gallon(20liter)bucketunderdrain.
3. Unlockdoor.
4. Openlowerrefrigerationdoor.
5. Stackthree(3)2x4’s(5cmx10cm)flatonthefloor
perpendiculartotherightsideofunit.Positionthese
boards1”(2.5cm)behindtherearofcaster.Thesethree
(3)boardswillbeusedtosupporttheunit.
6. Stacktwo(2)boards6”(15cm)awayandparallelto
frontofunit.Theseboardswillbeusedasafulcrumto
liftfrontofunit.
7. Slideone(1)board3”(8cm)underfrontofunitandlay
perpendicularontopoftwo(2)boardslayinginfront
ofunit.Thisboardwillbeusedasalevertoliftfrontof
unit.
8. Makesurelowerrefrigerationdoorisopen.Doormust
beopentopreventdamagetodoorandunit.
9. Onepersonshouldcarefullysteponendofleverwhile
secondpersonslidesthethree(3)boardstackunder
unit.
10.Verifythethree(3)boardstackisstableandexcessive
lengthofboardscanbeseenonbothsidesofunit.

Multiplex FreshBlender Specifications

General

Brand	Multiplex
Model	FreshBlender
Category	Dispenser
Language	English