TROUBLE SHOOTING
We have listed below a few basic checks in case your motorcycle is not functioning. If in case the problem is not rectified after these checks, it is necessary
to get the motorcycle checked by
a Royal Enfield Authorised Dealer / Service Center
to rectify the problem and to ensure trouble free performance.
S y m p t o m
Obse r vat i ons
Che ck fo r / Re med y
1. Ignition/Engine stop switch is in “OFF” position
2. Very low / No fuel in the fuel tank.
3. Lights / horn very dim
4. Electricals not working
5. Engine Cranking but not starting
Switch “ON” Ignition / Engine stop switch
Turn fuel tap to reserve position / Fill Fuel
Weak/Discharged battery. Replace Battery
1. Battery completely dead. Replace battery
2. Fuse Blown. Replace appropriate fuse.
Note: If fuse blows again, contact Authorised Service Center.
Spark plug Cap/wire disconnected. Reconnect.
Idling RPM setting in Carburetor is disturbed. Reset the
Idling RPM screw in Carburetor.
Carburetor Flooded. Shut off fuel tap, gently tap
Carburetor bottom and reopen fuel tap. Check if flooding has stopped.
Drain out entire fuel and Refill with fresh fuel from a reputed
filling station.
Excessive Engine temperature. Switch OFF Engine and allow
to cool down.
Clutch is Slipping. Check for sticky clutch/ clutch not having
any free play.
Adjust Rear chain to correct tension.
1. Typically happens after a Refill / Adulterated /
Water in Fuel
2. Motorcycle driven in Low gear / High RPM /
Crowded places for long time.
Engine RPM raises improportionately to motorcycle speed.
Rear Chain excessively loose causing chain to slip
on Sprocket.
Engine shuts off as soon as throttle is closed.
Eng in e D oe s
not s tar t
Poor Picku p
E n g i n e
Misfires & Runs
E r r a t ica lly /
Stops
Eng in e St art s
BU T shuts off
im mediate ly
To Next Page
Loading...
Need help?
General
