CAUTIONCAUTION
CAUTIONCAUTION
CAUTION
WW
WW
W
ARNING TO SERARNING TO SER
ARNING TO SERARNING TO SER
ARNING TO SER
VICE TECHNICIANSVICE TECHNICIANS
VICE TECHNICIANSVICE TECHNICIANS
VICE TECHNICIANS
PRECAUTIONS TO BE OBSERVED BEFORE AND DURING
SERVICING TO AVOID POSSIBLE EXPOSURE TO
EXCESSIVE MICROWAVE ENERGY
(a) Do not operate or allow the oven to be operated with the door open.
(b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other
microwave source, and make repairs as necessary :
(1) Interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other damage),
(4) damage to or loosening of hinges and latches, (5) evidence of dropping or abuse.
(c) Before turning on microwave power for any service test or inspection within the microwave generating
compartments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity,
and connections.
(d) Any defective or misadjusted components in the interlock, monitor, door seal, and microwave generation and
transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual before
the oven is released to the owner.
(e) A microwave leakage check to verify compliance with the Federal performance standard should be performed
on each oven prior to release to the owner.
REFERENCE NO. SS-860259
File No :File No :
File No :File No :
File No :
SUPPLEMENT OF SUPPLEMENT OF
SUPPLEMENT OF SUPPLEMENT OF
SUPPLEMENT OF
MicrMicr
MicrMicr
Micr
owave Ovenowave Oven
owave Ovenowave Oven
owave Oven
EM-P495WS (U.S.A.)EM-P495WS (U.S.A.)
EM-P495WS (U.S.A.)EM-P495WS (U.S.A.)
EM-P495WS (U.S.A.)
SER SER
SER SER
SER
VICE MANUALVICE MANUAL
VICE MANUALVICE MANUAL
VICE MANUAL
The following parts are different from the parts on model EM-P415WS (SM-860251)
Pr Pr
Pr Pr
Pr
oduct Code No.oduct Code No.
oduct Code No.oduct Code No.
oduct Code No.
437 499 03437 499 03
437 499 03437 499 03
437 499 03
See the Service Manual of EM-P415WS (SM-860251)
except the items described in this Service Manual.
Key
Part No. Description
No.
CAVITY PARTS
24 617 198 5580 Sensor Assy
25 617 198 5542 Duct, Sensor Assy
DOOR PARTS
1 617 207 6294 Door Cover
2 617 207 6300 Door Panel
Key
Part No. Description
No.
CONTROL PANEL PARTS
1 617 221 5853 Control Sheet
2 617 219 4578 Touch Key Board
3 617 207 6317 Control Frame
4 617 207 0377 Control Base
6 617 223 4816 Power & Control Circuit Board
9 617 207 0353 Door Release Lever
* 617 221 9424 Operating Instruction
* 617 223 5882 Carton Box Complete
* 617 223 5844 Name Plate
To Next Page
Need help?
General
