Form No. 3461-303 Rev A
T ransPro
™
648 T ow-Behind T railer
ProCore
®
648 or 648s Aerator
Model No. 09964 —Serial No. 323000000 and Up
Installation Instructions
Safety
• This trailer is intended for use with ProCore 648
and 648s machines only . T owing incompatible
products can result in damage to the trailer and/or
injury to the operator and bystanders. Refer to
Compatible Machines ( page 5 ) for a complete list
of compatible machines.
• Use only a vehicle with the proper tow rating; the
T ransPro 648 trailer and a ProCore aerator with
attachments has an approximate combined weight
of 1089 kg (2,400 lb). Ensure that the tow vehicle
has adequate braking and handling capacity by
checking the recommendations of the vehicle
manufacturer .
• Ensure that the trailer is properly connected to the
tow vehicle before loading or unloading the aerator
to prevent sudden unintended tongue movement
or ip-up. The trailer tongue should be parallel to
the ground when you align it with the tow vehicle
hitch.
• The trailer adds extra towing weight to the vehicle.
Drive the vehicle safely .
– Do not drive the machine on highways or public
roads.
– Always slow the tow vehicle when approaching
and while making a turn.
– Always slow the tow vehicle when driving in
unfamiliar areas or over rough terrain.
– Always slow the tow vehicle when changing
the direction of travel or preparing to stop.
– Always slow the tow vehicle when turning or
driving on slopes.
– Do not make sudden or sharp turns. Do not
suddenly change direction of travel on an
incline, ramp, grade, slope, or similar surface.
– The maximum towing speed is 15 mph (24
km/h). Always adjust the tow-vehicle speed to
allow for existing ground conditions, such as
wet slick surfaces, loose sand or gravel and/or
low visibility conditions, such as dim or bright
lighting, fog, mist, or rain.
– Be especially careful when driving a heavily
loaded vehicle down an incline or slope. Drive
the vehicle up and down the face of the slopes,
inclines, or grades whenever possible. Do not
drive across the face of a slope if at all possible.
There is a risk of upsetting the vehicle, which
can result in serious injury or death.
• Before backing up, look behind you and ensure
that it is clear of people and objects. Back up
slowly and watch the trailer movement closely .
• Use extreme caution and slow speed when
backing up the trailer and tow vehicle.
• W atch out for traf c when near or crossing roads.
Always yield the right of way to pedestrians and
other vehicles.
• If the trailer begins to vibrate abnormally , stop the
tow vehicle immediately . Shut of f the tow-vehicle
engine. Repair all damage before towing.
• Before servicing or making any adjustments to the
trailer , do the following:
– Stop the tow vehicle and engage the parking
brake.
– Shut of f the tow-vehicle engine and remove
the key .
• While the trailer is disconnected from tow vehicle:
– Store the trailer on level ground.
– Chock the wheels to prevent the trailer from
moving.
• Keep all fasteners tightened securely . Replace
any parts removed when servicing or making
adjustments.
© 2023— The T oro® Company
81 1 1 L yndale A venue South
Bloomington, MN 55420
Register at www .T oro.com.
Original Instructions (EN)
Printed in the USA
All Rights Reserved
*3461-303*
To Next Page
Need help?
General
