Chevrolet/GMC 6.6L Duramax Diesel Engine Supplement (GMNA-Localizing-
U.S./Canada-16504481) - 2023 - CRC - 9/26/22
Driving and Operating 25
At temperatures below 0 °C (32 °F), it is
recommended to avoid using biodiesel
blends above 5% blend. This blend may
cause fuel filter plugging, system gelling,
and freezing that may affect vehicle
starting. You may need to turn the ignition
on and off a few times before the vehicle
will start. Also, idle the vehicle for a couple
of minutes before accelerating.
It is recommended to use Ultra Low Sulfur
No. 1-D diesel fuel or a blend of No. 1-D and
No. 2-D diesel fuel to enhance vehicle
operation in cold weather at temperatures
below 0 °C (32 °F). Use of No. 1-D diesel fuel
may lower the fuel economy. For additional
information for better cold weather
operation, see Engine Heater 0 16.
Water in Fuel
Improper fuel tank inspection or cleaning,
or contaminated fuel from suppliers, can
cause water to be pumped into the fuel
tank along with the diesel fuel. If a WATER
IN FUEL SERVICE REQUIRED message displays,
the water must be drained immediately.
{
Warning
Diesel fuel containing water is still
combustible. You or others could be
burned. If the fuel needs to be drained,
keep sparks, flames, and smoking
materials away from the mixture.
Caution
Water in the diesel fuel can corrode
internal components of the fuel system
and lead to severe damage. It can also
support fungus or bacteria growth, which
can damage the fuel system. Even with a
diesel fuel biocide, the fuel system may
still need to be cleaned. Your dealer can
advise of the appropriate solution.
If the fuel tank needs to be purged to
remove water, see your dealer or a
qualified technician. Improper purging can
damage the fuel system.
Water in Fuel Troubleshooting
If the WATER IN FUEL SERVICE REQUIRED
message comes on:
Problem
Recommended
Action
Message displays
but goes off during
the ignition cycle.
The fuel filter is
partially filled with
water. Drain the
water as soon as
possible. See
"Removing Water
from the Fuel Filter"
following.
Message displays
and stays on.
Drain the fuel filter
immediately. If no
water can be
drained, and the
temperature is
below freezing, then
water may be
frozen in the filter.
Move the vehicle to
a warm location to
thaw the water,
then drain the fuel.
If water still does
not drain, see your
dealer.
To Next Page
Loading...
Need help?
General
