EUFAB JAMES User Manual

1 x
Lamp mount
2 x
Hexagonal screw M5 x 10
1 x
Lamp set with cable
2 x
Washer 15.8 x 8.3 x 1.2
1 x
Frame holder, short
6 x
Washer 17.6 x 6.5 x 1.1
1 x
Frame holder, long
4 x
Washer 11.9 x 6.5 x 0.9
1 x
License plate mount
2 x
Washer 5.4 x 5.2 x 0.9
2 x
2 x
Rail connector
Connecting element
4 x
6 x
Washer 13.7 x 5.4 x 0.9
Cable tie
2 x
Metal loop
1 x
Spanner 13/18
4 x
Wheel stopper
1 x
Spanner 8/10/13
6 x
Tensioning belt, small
1 x
Allen key 3 mm
1 x
Safety strap
2 x
Padlock with key, simultaneous locking
Specifications
Dead weight: 14 kg
Payload: 36 kg at 50 kg supporting load
46 kg at 60 kg supporting load
max. 50 kg at 75 kg supporting load
max. 50 kg at 90 kg supporting load
Material: Steel, aluminium
Electrical connection: 13-pin connector
Tow bar requirements
• The trailer tow bar must be approved in its construction.
• Ball and ball rod must have been forged in one piece.
• Only mount the bicycle rack to a coupling of steel St52-3, grey cast iron GGG52 or higher quality.
• The D-value of the tow bar ball must be at least 7.6 kN
• Never mount the rack to a tow bar made of aluminium, other light metals or plastic.
Unsuitable ball rods made from GGG40 are produced by Westfalia for the following vehicles:
Manufacturer
Test symbol
Suitable for
Westfalia
F 4192
Audi A4
F 3830
Audi A6
F 4112
Audi A8
Observe the instructions from the tow bar manufacturer. If in doubt, ask your manufacturer directly whether
their trailer tow bar is suitable.
Safety notes
Driving with a mounted bicycle rack will affect the driving characteristics of your vehicle.
• Adjust your speed to the new driving characteristics.
• Never drive faster than 130 km/h.
• Avoid sudden or jerky steering movements.
• Remember that your vehicle is longer than usual.
Personal injury or property damage due to loss of the bicycles.
Driving without safety straps can lead to accidents.
• Before embarking on any journey, check the correct and firm seating of the strap around the bicycles
and U-bracket of the rack.
• Before embarking on any journey check the correct and firm seating of both straps around the front
wheel and the strap around the rear wheel of the bicycle.
• If necessary tighten the straps again.
• Before embarking on any journey, check to make sure the straps used are undamaged and not worn.
• Damaged or worn straps must be replaced with undamaged ones before you embark on your journey.
Only straps authorised by EAL GmbH for the purpose may be used.
Personal injury or property damages caused by protruding parts.
Parts protruding beyond the edge of the vehicle or rack may cause personal injury or property
damage during the journey.
• Only mount parts that do not protrude beyond the edge of the vehicle.
Personal injury or property damage due to overloading.
Exceeding the maximum payload of the bicycle rack and the permitted supporting load of the trailer tow bar
or permitted overall weight may lead to serious accidents.
• Always observe the specifications regarding the maximum payload, permitted supporting load and
permitted overall weight of your vehicle. Do not exceed these specifications at any time.

EUFAB JAMES Specifications

General

Brand	EUFAB
Model	JAMES
Category	Automobile Accessories
Language	English