General:
:$51,1*
Do not attempt to repair any components of heat-
er. Do not modify heater in any manner. To do so may result in a
malfunction which could result in death, personal injury, or proper-
W\GDPDJH&KHFNZLWKFRQVXPHUWRVHHLIDQ\SDUWRIKHDWHUKDV
been under water. Replace any part of the control system and any
gas control which has been under water. Never use or attempt to
use parts that have been previously used.
&$87,21
Label all wires prior to disconnection when servic-
ing controls. Wiring errors can cause improper and dangerous
operation. Verify proper operation after servicing.
Burner cleaning:
If required, burners can be cleaned in the following
manner:
7XUQSXPSPDLQJDVYDOYHDQGKHDWHUSRZHURII
2. Remove the gas manifold.
5HPRYHWKHEXUQHUV
%UXVKEXUQHUVZLWKDZLUHEUXVKDQGFKHFNWKDWWKH\DUHIUHHRI
OLQWGXVWDQGVSLGHUZHEVEHIRUHHDFKVHDVRQRIXVH%XUQHUV
with damaged ports must be replaced.
Gas valve replacement:
:$51,1* Do not attempt to repair gas valve. If found
to be defective, replace entire valve. Attempts to repair it
will void warranty.
7XUQSXPSPDLQJDVYDOYHDQGKHDWHUSRZHURII
2. Disconnect wires to gas valve.
8QVFUHZJDVYDOYHIURPPDQLIROG
,QVWDOOQHZYDOYH
5HFRQQHFWZLUHVWRJDVYDOYH
Direct spark module:
7KHGLUHFWVSDUNLJQLWLRQPRGXOHLVWKHPDVWHUFRQWUROSUR-
cessing the operational information from the other controls. When
WKHWKHUPRVWDWFDOOVIRUKHDWWKHEORZHUWXUQVRQIRUVHFRQGV
EHIRUHWKHLJQLWRUEHJLQVWRVSDUN7KHLJQLWRUEHJLQVVSDUNLQJ
at the same time the main gas valve opens, which causes igni-
WLRQRIWKHPDLQEXUQHUJDV,ILJQLWLRQGRHVQRWKDSSHQZLWKLQ
VHFRQGVWKHPRGXOHZLOOWU\WROLJKWIRUFRQVHFXWLYHWULHVDW
VHFRQGLQWHUYDOV,IQRLJQLWLRQLVUHFHLYHGWKHFRQWUROZLOOORFNRXW
IRUKRXU7RUHVHWWKHPRGXOHWKHWKHUPRVWDWPXVWEHWXUQHGWR
WKH³2))´SRVLWLRQDQGEDFN³21´
7RUHSODFHWKHPRGXOH
7XUQSXPSPDLQJDVYDOYHDQGKHDWHUSRZHURII
8QSOXJKHDWHU
'LVFRQQHFWZLUHVIURPWKHPRGXOH
5HPRYHPRGXOHUHWDLQLQJVFUHZV
5HSODFHPRGXOH
Combustion blower:
The combustion blower provides the air that mixes with the
gas from the main burners for the combustion process. On initial
VWDUWXSWKHEORZHURSHUDWHVIRUVHFRQGVWRSXUJHJDVRXWRI
WKHKHDWHU7KHQWKHPDLQJDVYDOYHRSHQVWKHLJQLWRUVSDUNVIRU
DPD[LPXPRIVHFRQGVDQGWKHKHDWHUOLJKWV7KHEORZHURSHU-
ates the entire time the gas valve is open.
&RPEXVWLRQEORZHUUHSODFHPHQW
7XUQSXPSPDLQJDVYDOYHWKHUPRVWDWDQG
KHDWHUSRZHU³2))´
2. Remove screws retaining the main top.
'LVFRQQHFWZLUHVDWWDFKHGWRWKHEORZHU
5HPRYHH[WHUQDOYHQWWHUPLQDO
5HPRYHGXFWIURPEORZHUWRYHQWWHUPLQDO
5HPRYHVFUHZVDWWDFKLQJEORZHUWRIOXHFROOHFWRU
7. Replace blower.
5HYHUVHDERYHSURFHGXUHIRULQVWDOODWLRQ
Section IV. Qualified Technician - Servicing
6