-22-
CAUTION
The usage of the battery
It will explode to cause a severe accident if the battery used in a wrong way.
Remove the negative terminal when servicing the generator.
NOTE
Breaker can prevent the electric shock. If need to replace, please replace one
that has equal degree and performance.
-11-
4. WARM-UP PROCEDURE
1. Check the fuel before every start.
2. Check if the engine oil reaches the scale of stipulating.
3. Check the water lever, and fill the cooled-water full.
4. Check the fan strap's degree of tightness
5. Set the main switch to OFF.
6. Turn the engine start key to START position.
7. Warm-up time is about 3-5 minutes.
8. Speed controller has adjusted well before transporting. So don't adjust it at
random, or it will cause the engine rotation speed too high or too low.
9. The battery is optional for generator, to install right battery according with the
generator before start.
2. Judge and elimininate troubles
Start motor run
but doesn't start
Start motor doesn't run
or it's speed is so slow
Ambient temperature
is very low
Battery leakage
Battery unclamped or rut
Start switch badness
Starter badness
The wire breaks
No fuel oil
Fuel oil cleaner walled up
Air in the oil pipe
Liquid measure
Install after cleaning
Repair
Replace
Replace
Repair
Fill oil
Clean , and replace fuel oil cleaner
Empty air
Stop automatic,
rotate speed
doesn't rise
Some water accumulated in
the fuel system is frozen.
Fuel is frozen
Fuel winding does not work
Empty air
Mend the engine
Replace air cleaner element
Use winter oil, or choose the applicable
viscosity oil according to the freeze area
Check the fuse, if disconnection, replace
it ,check and replace winding if necessary
Heat, empty fuel oil tank ,fuel oil cleaner
and water in oil pipe
Replace fuel oil cleaner element, clean or replace filter
Bad Air around pipe
Fuel oil cleaner walled up
Badness water of pipe oil
Air cleaner is clogged.
Engine doesn't run
The earth terminal is imperfect
To Next Page
Loading...
Need help?
General
