Specifications Cont.
Model: ................................................................. SV540 ............................... SV590 .................................. SV600
Sore: .................................... mm (in.) ................ 89 (3.50) ...........................94 (3.70) ..............................94 (3.70)
Stroke:.................................. mm (in.) ................ 86 (3.38) ........................... 86 (3.38) .............................. 86 (3.38)
Displacement: ...................... cc (cu. in.) ............. 535 (32.6) ......................... 597 (36.4) ............................ 597 (36.4)
Power (at 3600 RPM): ......... kW (HP) ............... 13.4 (18") .......................... 14.1 (19") ............................. 14.9 (20*)
Max. PeakTorque @ RPM: .. N.m (ft. lb.) ........... 43.5 (32.1) @2200 ............ 48.8 (36) @2200 ................. 50 (36.9) @2200
Compression Ratio: ............................................ 8.5:1 .................................. 8.5:1 ..................................... 8.5:1
Weight: ................................. kg (lb.) .................. 35.8 (79) ........................... 35.8 (79) .............................. 35.8 (79)
Oil Capacity w/filter: ............. L (U.S. qt.) ............ 1.5 (1.6) ............................ 1.5(1.6) ............................... 1.5(1.6)
Lubrication: ........................ Full Pressure w/Full Flow Filter
*Horsepower ratings exceed Society of Automotive Engineers Small Engine Test Code J 1940. Actual engine
horsepower is lower and affected by, but not limited to, accessories (air cleaner, exhaust, charging, cooling, fuel
pump, etc.), application, engine speed and ambient operating conditions (temperature, humidity, and altitude).
Kohler reserves the right to change product specifications, designs and equipment without notice and without
incurring obligation.
Operating instructions
Also read the operating instructions of the equipment this engine powers.
Pre-Start Checklist
• Check oil level. Add oil if low. Do not overfill.
• Check fuel level. Add fuel if low.
• Check cooling air intake areas and external
surfaces of engine. Make sure they are clean and
unobstructed.
4. Use fresh winter grade fuel. NOTE: Winter grade
gasoline has higher volatility to improve starting.
Do not use gasoline left over from summer.
Starting
1. a. For a Single-Lever Throttle/Choke Control:
Place the lever into "fast/choke on" position.
See Figure 5.
• Check that the air cleaner components and all
shrouds, equipment covers, and guards are in
place and securely fastened.
Check that any clutches or transmissions are
disengaged or placed in neutral. This is especially
important on equipment with hydrostatic drive. The
shift lever must be exactly in neutral to prevent
resistance which could keep the engine from
starting.
WARNING: Lethal Exhaust Gases!
Engine exhaust gases contain poisonous carbon
monoxide. Carbon monoxide is odorless, colorless,
and can cause death if inhaled. Avoid inhafing exhaust
fumes, and never run the engine in a closed building or
confined area.
b,
For Separate Levers: Place the throttle
control midway between the "slow" and
"fast" positions. Place the choke control into
the "on" position.
Cold Weather Starting Hints
1. Be sure to use the proper oil for the temperature
expected. See Figure 2 on page 4.
2. Declutch all possible external loads.
3. Awarm battery has much more starting capacity
than a cold battery,
Figure 5. Throttle Position for Starting Engine with
Single-Lever Control.
To Next Page
Loading...
Need help?
General