90-830234R3 DECEMBER 19971D-0 - IMPORTANT INFORMATION
Table of Contents
Page
Determining Recommended Outboard
Mounting Height 1D-1. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Notice to Installer and Owner 1D-2. . . . . . . . . . . . . . . . . .
Boat Horsepower Capacity 1D-2. . . . . . . . . . . . . . . . .
Outboard Remote Control 1D-2. . . . . . . . . . . . . . . . . .
Selecting Accessories For The Outboard 1D-2. . . . .
Selecting Steering Cables and Remote Control
Cables 1D-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Locate Center line Of The Outboard 1D-3. . . . . . . . .
Drilling Outboard Mounting Holes 1D-3. . . . . . . . . . . .
Lifting Outboard 1D-4. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastening Outboard To The Transom 1D-4. . . . . . . .
Single Steering Cable and Steering Link
Rod Installation 1D-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installing Ride Guide Steering Cable to the
Outboard 1D-5. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Link Rod Installation 1D-5. . . . . . . . . . . . . . .
Co-Pilot Installation (Tiller Handle models) 1D-6. . . . . . .
Remote Control Installation 1D-7. . . . . . . . . . . . . . . . . . . .
Required Side Mount Remote Control or Ignition
Key Switch Assembly 1D-7. . . . . . . . . . . . . . . . . . . . . . . . .
Boats Equipped with Side Mount
Remote Control 1D-7. . . . . . . . . . . . . . . . . . . . . . . . . . .
Boats Equipped with Panel Or Console Mount
Remote Control 1D-7. . . . . . . . . . . . . . . . . . . . . . . . . . .
Connecting Remote Wiring Harness to the Engine 1D-7
Shift and Throttle Cable Installation to the Outboard1D-8
Shift Cable Installation 1D-8. . . . . . . . . . . . . . . . . . . . .
Throttle Cable Installation 1D-9. . . . . . . . . . . . . . . . . .
Battery Connections 1D-10. . . . . . . . . . . . . . . . . . . . . . . . .
Set Up Instructions For Oil Injection System 1D-10. . . .
Filling The Oil Injection System 1D-10. . . . . . . . . . . . .
Bleeding Air From The Oil Injection System 1D-11. .
Adjusting The Oil Injection Pump 1D-11. . . . . . . . . . .
Trim Tab Adjustment 1D-12. . . . . . . . . . . . . . . . . . . . . . . . .
To Next Page
Loading...
Need help?
General
