Rheem Residential 30 - User Manual

AP16801 (04/13)
FOR YOUR SAFETY!
— Do not store or use gasoline or other
flammable vapors or liquids or other
combustible materials in the vicinity of this or
any other appliance. To do so may result in an
explosion or fire.
— WHAT TO DO IF YOU SMELL GAS
● Do not try to light any appliance.
● Do not touch any electrical switch; do not
use any phone in your building.
● Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.
● If you cannot reach your gas supplier, call
the fire department.
● Do not return to your home until authorized
by the gas supplier or fire department.
— Improper installation, adjustment, alteration,
service or maintenance can cause property
damage, personal injury, or death. Refer to
this manual. Installation and service must be
performed by a qualified installer, service
agency or the gas supplier.
WARNING: If the information in these instructions is not followed exactly,
a fire or explosion may result causing property damage, personal injury or death.
The purpose of this manual is twofold: one, to provide the installer with the basic directions
and recommendations for the proper installation and adjustment of the water heater; and two,
for the owner–operator, to explain the features, operation, safety precautions, maintenance and
troubleshooting of the water heater. This manual also includes a parts list.
It is imperative that all persons who are expected to install, operate or adjust this water heater
read the instructions carefully so they may understand how to perform these operations. If you
do not understand these instructions or any terms within it, seek professional advice.
Any questions regarding the operation, maintenance, service or warranty of this water heater
should be directed to the seller from whom it was purchased. If additional information is
required, refer to the section on “If you need service.”
Do not destroy this manual. Please read carefully and keep in a safe place for future
reference.
Recognize this symbol as an indication of Important Safety Information!
California Proposition 65 Warning: This product contains chemicals known to the
State of California to cause cancer, birth defects or other reproductive harm.
Residential 30, 38, 40, 50 and 60 Gallon with Electronic Control
Use & Care Manual
With Installation Instructions for the Installer
Printed in USA
Water Heaters
Residential Gas - FVIR Certified
D
E
S
I
G
N
C
E
R
T
I
F
I
E
D
®
!
WARNING: This water heater is not suitable
for use in manufactured (mobile) homes!
!
!
!
!

Summary

Safety Symbols and Definitions

Safety Alert Symbols and Terms

Explains the meaning of DANGER, WARNING, CAUTION, and NOTICE symbols.

Installation Safety Hazards

DANGER: Draft Hood and Venting Risks

Risks associated with improper draft hood installation and venting.

WARNING: Flammable Material Hazards

Dangers of storing or using flammable substances near the water heater.

Water Temperature Safety Dangers

DANGER: Scalding Hazard

Risks of severe burns or death from high water temperatures.

Gas Safety and Leak Response

LP and Natural Gas Hazards

Dangers associated with LP and natural gas, and conversion warnings.

Gas Leak Emergency Actions

Steps to take if a gas leak is detected.

Water Heater Installation Location and Clearances

Location Requirements

Clearance Requirements

Details minimum distances from combustible materials.

Combustion Air Requirements and Environment

Combustion and Ventilation Air

Relief Valve and Filling Procedures

Relief Valve Installation

Gas Supply, Testing, and Altitude

Gas Supply Requirements

Leak Testing Procedures

Methods for testing gas connections for leaks.

Insulation and Venting Installation

Venting System Installation

Proper installation and testing of the venting system.

Installation Dos and Donts

Installation Best Practices

Installation Checklist

Location and Supply Checklists

Valve and Venting Checklists

Lighting the Water Heater

Safety Before Lighting

Critical safety steps to perform before attempting to light the unit.

Pilot Lighting Instructions

Step-by-step instructions for lighting the pilot burner.

Operating the Water Heater

Operating Safety Precautions

Water Temperature Settings

Guidance on adjusting and setting the water temperature.

Water Temperature and Control Details

Combination Gas Control Operation

Water Heater Care and Cleaning

Draining and Preventative Maintenance

Troubleshooting Common Issues

Condensation, Flame, and Pilot Issues

Common problems like condensation, flame appearance, and pilot light issues.

Troubleshooting Performance Issues

Noise and Hot Water Problems

Status Light Troubleshooting

Understanding Status Light Codes

Explanation of different status light codes and their conditions.

Troubleshooting with Status Lights

Potential solutions for issues indicated by status light codes.

Rheem Residential 30 Specifications

General

Brand	Rheem
Model	Residential 30
Category	Water Heater
Language	English