Simplicity 2690445 - User Manual

Questions and Answers

S
Stephen ClineSep 12, 2025
What causes stepped cutting with my Simplicity 2690445?
- J
  Janice HooperSep 12, 2025
  Stepped cutting with your Simplicity Lawn Mower can be caused by several factors. Ensure the deck is leveled correctly and the tires are properly inflated. Check for damaged blades and replace them if necessary. Damage to the deck shell may also be a cause, requiring repair or replacement. Inspect the mower spindle for bends or looseness, and repair or replace it if needed. Finally, ensure the blades are installed correctly.
C
Cheryl DominguezAug 25, 2025
How to fix Simplicity 2690445 Lawn Mower that starts hard?
- C
  cvaughnAug 25, 2025
  If your Simplicity Lawn Mower starts hard or runs poorly, the fuel mixture might be too rich. Try cleaning the air filter and checking the choke adjustment. Also, inspect the spark plug; clean and gap it, or replace it if necessary.
A
Anthony PattersonAug 27, 2025
What causes the drive belt to slip on my Simplicity 2690445 Lawn Mower?
- N
  Natasha MooreAug 27, 2025
  If the drive belt on your Simplicity Lawn Mower is slipping, it could be due to greasy or oily pulleys or belt, which should be cleaned. The tension might also be too loose, requiring adjustment of the spring tension. Alternatively, the belt may be stretched or worn and need replacement.
R
Ronald McdonaldAug 27, 2025
Why does the mower drive belt slip or fail on my Simplicity Lawn Mower?
- J
  Jason LongAug 27, 2025
  If the mower drive belt slips or fails to drive on your Simplicity Lawn Mower, the idler pulley spring might be broken or not properly attached; repair or replace it as needed. Alternatively, the mower drive belt itself may be broken and require replacement.
D
dthompsonAug 29, 2025
How to prevent streaking with Simplicity Lawn Mower?
- M
  Monica ThompsonAug 29, 2025
  To prevent streaking while mowing with your Simplicity Lawn Mower, ensure the blades are sharp and not worn down. Always mow at full throttle and avoid moving too fast. Clean out the mower deck if it's plugged with grass. Overlap your cutting rows, especially when turning where the effective cutting width decreases.
L
Lisa BradleyAug 31, 2025
What to do if Simplicity 2690445 engine stalls when mower is engaged?
- M
  Michael BrownAug 31, 2025
  If your Simplicity Lawn Mower engine stalls easily when the mower is engaged, ensure the engine is set to full throttle. Also, decrease your ground speed. If you're cutting tall grass, raise the cutting height for the first pass. Ensure the discharge chute isn't jamming with cut grass by mowing with the discharge pointing toward the previously cut area.
C
Candace TaylorNov 20, 2025
Why Simplicity Lawn Mower engine will not start?
- M
  Michelle GarciaNov 20, 2025
  If your Simplicity Lawn Mower engine won't start, several factors could be responsible. Here's what to check: * Ensure the parking brake is engaged. * Make sure the PTO (electric clutch) switch is in the OFF position. * Verify that the fuel tank isn't empty; if it is, and the engine is cool, refill it. * If the engine is flooded, move the choke control to the closed position. * Inspect and replace any blown fuses. * Clean any corrosion from the battery terminals. * Recharge or replace a discharged or dead battery. * Check for and repair any loose or broken wiring. * Faulty components like the solenoid or starter motor, or a safety interlock switch, may need professional repair or replacement. Also, check, clean, gap, or replace faulty, fouled, or incorrectly gapped spar...
B
Barbara ReynoldsSep 13, 2025
Why does my Simplicity 2690445 steer poorly?
- A
  Ashley CastroSep 13, 2025
  Poor steering or handling in your Simplicity Lawn Mower can be due to a loose steering linkage; check and tighten any loose connections. Also, improper tire inflation can affect steering, so ensure your tires are inflated correctly.
X
xfranklinSep 10, 2025
Why is my Simplicity Lawn Mower using too much oil?
- K
  kmirandaSep 10, 2025
  Excessive oil consumption in your Simplicity Lawn Mower can occur if the engine is running too hot; clean the engine fins, blower screen, and air cleaner. Using the wrong weight oil can also contribute, so consult your engine manual. Additionally, too much oil in the crankcase can cause this issue, so drain any excess oil.
E
Ebony SmithSep 6, 2025
Why is my Simplicity 2690445 Lawn Mower engine knocking?
- A
  amberpalmerSep 6, 2025
  An engine knocking in your Simplicity Lawn Mower could be due to a low oil level, so check and add oil as required. It could also be due to using the wrong grade of oil; consult your engine manual for the correct type.

Simplicity 2690445 Specifications

General

Brand	Simplicity
Model	2690445
Category	Lawn Mower
Language	English

Summary

Safety Rules and Information

Operating Safety

General safety advice for operating the machine.

Read the Manual

Importance of reading and understanding the operator's manual.

Children Safety

Safety precautions regarding children around the operating area.

Safety Rules and Information

Slope Operation

Safety guidelines for operating the machine on slopes.

Thrown Objects

Hazards associated with thrown objects from mower blades.

Moving Parts

Safety precautions related to the machine's moving parts.

Safety Rules and Information

Roll Bar Use

Instructions and warnings for using the roll bar.

Hazards Near Water and Edges

Hazards associated with operating near retaining walls, drop-offs, and water.

Overhead Obstacles

Precautions for driving under overhead obstacles.

Safety Rules and Information

Fuel and Maintenance Safety

Safety guidelines for refueling and maintaining the unit.

Enclosed Areas Warning

Warnings about operating the unit in enclosed or unventilated areas.

Safety Rules and Information

General Operation Safety

Comprehensive safety rules for operating the machine.

Transporting and Storage Safety

Safety guidelines for transporting and storing the unit.

Safety Rules and Information

Slope Operation Details

Detailed safety rules for operating on slopes.

Towed Equipment Safety

Safety guidelines for towing equipment with the unit.

Children and Mowing Safety

Safety precautions regarding children and operating equipment.

Safety Rules and Information

Safe Handling of Gasoline

Guidelines for safely handling gasoline and preventing fires.

Safety Rules & Information

Roll Bar Instructions

Guidelines and warnings for operating with a roll bar.

Roll Bar Structure Inspection

Procedures for inspecting the roll bar structure.

Safety Rules & Information

Seat Belt Inspection and Maintenance

Procedures for inspecting and maintaining the seat belt.

Identification Numbers

Identification Tag Location

Location and purpose of the identification tag on the machine.

CE Identification Tag Markings

Explanation of markings found on the CE identification tag.

Safety Decals

Safety Decals Overview

Information about safety labels on the rider and mower.

Safety Icons & Interlock System

Safety Interlock System

Explanation of the unit's safety interlock switches and their function.

Safety Icons Explained

Explanation of safety alert symbols and hazard levels.

Features & Controls

Control Locations Diagram

Diagram showing the location of various controls on the machine.

Control Functions Overview

Description of individual control functions and their operation.

Features & Controls

Engine Controls

Covers choke, ignition, and throttle for engine operation.

Drive and PTO Controls

Explains PTO switch and ground speed levers for machine movement.

Operator Station Features

Details seat adjustment, lighting, hour meter, and fuel indicators.

Operation

General Operating Safety

Essential safety practices before operating the tractor and mower.

Checks Before Starting

Pre-operation checks to ensure safety and proper function.

Operation

Starting the Engine

Step-by-step instructions for starting the engine.

Stopping the Rider

Procedures for safely stopping the rider.

Pushing the Rider by Hand

Instructions for disengaging the drive system to push the unit.

Operation

Zero Turn Driving Practice

Guidance on practicing zero-turn maneuvers for smooth operation.

Basic Driving Techniques

Instructions for forward and reverse travel practice.

Operation

Turning Around a Corner

Practice techniques for turning the rider around a corner.

Turning In Place

Practice techniques for performing a zero-turn maneuver.

End-Of-Row Zero Turn Execution

Step-by-step guide for performing an end-of-row zero turn.

Operation

Raise & Lower the Roll Bar

Instructions for raising and lowering the roll bar for safety.

Storage Procedures

Guidelines for storing the unit, especially for off-season.

Operation

Mowing Procedure

Steps to follow before and during mowing operations.

Mowing Recommendations

Factors and tips for optimal mowing performance and lawn care.

Operation

Grass Height and Cutting

Guidance on selecting the appropriate cutting height for grass.

Mowing Methods

Explanation of different mowing techniques like broadcasting.

Operation

Proper Mulching Technique

Explanation of mulching technique and conditions.

Mulching Requirements

Conditions necessary for effective mulching operation.

Broadcasting Speed Settings

Recommended engine and ground speed settings for broadcasting.

Attaching a Trailer

Instructions and weight limits for attaching a trailer.

Regular Maintenance

Maintenance Schedule

Schedule for regular maintenance tasks based on operating hours.

Regular Maintenance

Tire Pressure Checks

Procedure for checking and maintaining tire pressure.

Fueling Procedures

Steps for safely checking and adding fuel to the unit.

Fuel Filter Maintenance

Instructions for replacing the fuel filter.

Engine Oil and Filter Change

Procedure for changing the engine oil and filter.

Regular Maintenance

Lubrication Points

Locations and types of lubrication required for the unit.

Front Caster Lubrication

Specific instructions for lubricating the front casters.

Regular Maintenance

Hydraulic Oil Level Check

Procedure for checking the hydraulic oil level.

Hydraulic Oil Filter Change

Instructions for changing the hydraulic oil filter.

Battery Maintenance

General maintenance for the unit's battery.

Regular Maintenance

Servicing Mower Blades

Instructions for sharpening, balancing, and installing mower blades.

Troubleshooting, Adjustment & Service

Troubleshooting the Rider

Common problems and remedies for the rider unit.

Troubleshooting, Adjustment & Service

Rider Troubleshooting Continued

Additional common problems and remedies for the rider unit.

Troubleshooting the Mower

Common problems and remedies for the mower deck.

Troubleshooting, Adjustment & Service

Troubleshooting Common Cutting Problems

Solutions for common issues affecting grass cutting quality.

Troubleshooting, Adjustment & Service

Seat Adjustment

How to adjust the operator's seat for comfort.

Ground Speed Control Lever Adjustment

Adjustments for control lever alignment, placement, and height.

Speed Balancing Adjustment

Procedure to balance speed between left and right drive wheels.

Troubleshooting, Adjustment & Service

Parking Brake Adjustment

Steps to adjust the parking brake for proper function.

Battery Charging

Instructions and warnings for charging the unit's battery.

Troubleshooting, Adjustment & Service

Rear Suspension Adjustment

Adjusting spring pre-load and upper mounting position for ride comfort.

Troubleshooting, Adjustment & Service

PTO Clutch Adjustment

Procedure for adjusting the PTO clutch for proper engagement.

Blade Brake Check

How to check the mower blade stopping time.

Troubleshooting, Adjustment & Service

Return-to-Neutral Adjustment

Adjusting the neutral return rod for proper lever alignment.

Neutral Adjustment

Adjusting linkage rod to prevent tractor creep when in neutral.

Troubleshooting, Adjustment & Service

Mowing Height Adjustment

How to adjust the mower deck cutting height.

Foot Pedal Adjustment

Adjusting the deck lift foot pedal position for operator comfort.

Troubleshooting, Adjustment & Service

Deck Leveling Adjustment

Procedure for leveling the mower deck for optimal cutting.

Troubleshooting, Adjustment & Service

Hydraulic Pump Drive Belt Replacement

Steps for replacing the hydraulic pump drive belt.

Troubleshooting, Adjustment & Service

Mower Belt Replacement

Instructions for replacing the mower deck drive belt.

Specifications

Engine Specifications

Details on engine make, model, horsepower, and displacement.

Transmission Specifications

Details on transmission type, fluid, speeds, and torque.

Machine Dimensions and Weight

Overall length, width, height, and weight of the machine.

Engine Power Rating Information

Explanation of engine power rating standards and factors affecting output.

Technical Manuals

Information on obtaining additional service and parts manuals.

Product Quick Specs

Engine Quick Specs

Summary of engine specifications.

Chassis Quick Specs

Summary of chassis details like fuel tank and tire size.

Belts and Blades Information

Part numbers for mower belts and blades.

Related product manuals

Simplicity Champion 2690449

70 pages

Simplicity 2690487

48 pages

Simplicity Cobalt 2690479

Simplicity Regent 2690783

44 pages

Simplicity Prestige 2690680

68 pages

Simplicity 2691127-0

40 pages

Simplicity 2691481-00

192 pages

Simplicity Broadmoor 2691467

68 pages

Simplicity 2690445 - User Manual

Table of Contents

Questions and Answers

Simplicity 2690445 Specifications

Summary

Safety Rules and Information

Operating Safety

Read the Manual

Children Safety

Safety Rules and Information

Slope Operation

Thrown Objects

Moving Parts

Safety Rules and Information

Roll Bar Use

Hazards Near Water and Edges

Overhead Obstacles

Safety Rules and Information

Fuel and Maintenance Safety

Enclosed Areas Warning

Safety Rules and Information

General Operation Safety

Transporting and Storage Safety

Safety Rules and Information

Slope Operation Details

Towed Equipment Safety

Children and Mowing Safety

Safety Rules and Information

Safe Handling of Gasoline

Safety Rules & Information

Roll Bar Instructions

Roll Bar Structure Inspection

Safety Rules & Information

Seat Belt Inspection and Maintenance

Identification Numbers

Identification Tag Location

CE Identification Tag Markings

Safety Decals

Safety Decals Overview

Safety Icons & Interlock System

Safety Interlock System

Safety Icons Explained

Features & Controls

Control Locations Diagram

Control Functions Overview

Features & Controls

Engine Controls

Drive and PTO Controls

Operator Station Features

Operation

General Operating Safety

Checks Before Starting

Operation

Starting the Engine

Stopping the Rider

Pushing the Rider by Hand

Operation

Zero Turn Driving Practice

Basic Driving Techniques

Operation

Turning Around a Corner

Turning In Place

End-Of-Row Zero Turn Execution

Operation

Raise & Lower the Roll Bar

Storage Procedures

Operation

Mowing Procedure

Mowing Recommendations

Operation

Grass Height and Cutting

Mowing Methods

Operation

Proper Mulching Technique

Mulching Requirements

Broadcasting Speed Settings

Attaching a Trailer

Regular Maintenance

Maintenance Schedule

Regular Maintenance