’02 Tacoma U (L/O 0109)
289
2002 MY TACOMA_U (OM35786U)
DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.):
Two–wheel drive models except Pre
Runner
2RZ–FE engine 1.35 (1.4, 1.2)
5VZ–FE engine 2.55 (2.7, 2.2)
Four–wheel drive models and Pre
Runner
Front (except Pre Runner)
1.15 (1.2, 1.0)
Rear
Short wheel base
With rear differential lock system
2.65 (2.8, 2.3)
Without rear differential lock sys-
tem
2.55 (2.7, 2.2)
Extra long wheel base
With rear differential lock system
2.95 (3.1, 2.6)
Without rear differential lock sys-
tem
2.45 (2.6, 2.2)
Oil type:
Hypoid Gear Oil API GL–5
Recommended oil viscosity:
Front
SAE 75W–90
Rear
Above –18C (0F)
SAE 90
Below –18C (0F)
SAE 80W or 80W–90
CHASSIS LUBRICATION
Wheel bearings:
Lithium base wheel bearing grease,
NLGI No.2
Front drive shaft thrust bushings:
Synthetic oil and lithium soap base
chassis grease, NLGI No.1
Propeller shafts:
Spiders
Lithium base chassis grease, NLGI
No.2
Slide yoke and double cardan joint
Molybdenum–disulfide lithium base
chassis grease, NLGI No.2
BRAKES
Minimum pedal clearance when depressed
with a pressure of 490 N (50 kgf, 110 lbf)
when the engine is stopped and after de-
press the brake pedal several times, mm
(in.):
105 (4.1)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf):
12—18 clicks
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONII
or III
To Next Page
Loading...
Need help?
General
