Aode Machinery Co., Ltd Page 12 of 26
奥德机械有限公司 2012
第六章 安装及注意事项
Chapter Six Installation and Precaution
6.1 注意事项 Precautions
6.1.1) 本机仅可使用机箱铭牌的标示之三相电压及频率，地线 (黄绿色)务必接地。
This machine can only use three-phase voltage and frequency indicated on the nameplate
and the earth wire (yellow and green) must be GND.
6.1.2) 机器运转时请务必将冷却水出入口及有铁氟龙管连接的热水出入口阀门开启。
Please do open the outlet/inlet of cooling water and hot water outlet/inlet valves
connected with Teflon pipe when running the machine.
6.1.3) 外部配管请参考以下使用之温度，选择外部配管：
Please refer to the following temperature for external pipe and make your choice:
A）棉纱管 60℃ 约半年
Cotton yarn pipe 60℃ about half a year
B）中压皮管 120℃ 约一年
Intermediate pressure leather hose 120℃ about one year
C）铁氟龙管 200℃ 约一年
Teflon pipe 200℃ about one year
注：管路接头于 120℃以下可使用快速接头，高于此温度一定要使用油压接头，因管路压
力大，请勿使用插芯及管束。
Notes: Quick coupler is suitable when temperature is below 120℃, but oil-pressure
coupler must be used when it is above 120℃. DO NOT use plug and tube bundle
since the pressure of pipeline is high.
6.1.4) 介质（水）Medium (water)
A）、不含沙及泥土或其他杂质的干净水源，如使用地下水需经软化处理。
Clean water source without sand and clay or other impurities, and ground water
should be softening process first.
B）、每月定时更换循环水。
Change circulating water every month.
C）、定期添加防锈剂及除藻剂。
Add antirust agent and algaecide regularly.
注：杂质易堵塞管路造成机台损坏，未经软化的地下水会造成水垢，严重影响加热及传热
效率，缩短发热管寿命。
Notes: Impurities block pipelines may cause machine damage easily, unsoftened ground
water may cause furr, thus affect heating and heat transfer efficiency and shorten
the service life of heating pipe.
To Next Page
Loading...
Need help?
General