Edwards RV3 Service Manual

© Edwards Limited 2018. All rights reserved. Page 13
Edwards and the Edwards logo are trademarks of Edwards Limited.
Maintenance kits
A652-01-840 Issue P
3 Maintenance kits
When you maintain this Edwards product, we recommend you use only Edwards maintenance and service kits.
The maintenance kits available for the RV pumps are listed in Table 2 below:
Table 2 - Maintenance kits
Table 2
Cross
Reference
Description
Item Number
Hydrocarbon PFPE Variants
1 Clean and overhaul kit (standard) A652-01-131 A652-01-131
2 RV3 blade kit A652-01-130 A652-01-130
3 RV5 blade kit A653-01-130 A653-01-130
4 RV8 blade kit A654-01-130 A654-01-130
5 RV12 blade kit A655-01-130 A655-01-130
6 RV3 cartridge kit A652-01-032 A652-09-032
7 RV5 cartridge kit A653-01-032 A653-09-032
8 RV8 cartridge kit A654-01-032 A654-09-032
9 RV12 cartridge kit A655-01-032 A655-09-032
10 Inlet-valve kit A652-01-036 A652-01-036
11 Motor starting relay kit A505-74-000 A505-74-000
12 Outer shaft-seal kit A652-01-134 A652-01-134
13 Rotor sleeve kit A652-01-136 A652-09-136
14
*
*
As of the end of 2010 the four RV 1-phase motors (used in kits 14, 15, 16 and 17) have been made obsolete
and replaced by two new motors (items 401). These are supplied in kits 22 and 23.
RV3/RV5 motor kit (Europe/USA)
50/60 Hz, 250/300 W, 1 phase 110-120/220-240 V
A652-99-000 A652-99-000
15
*
RV8/RV12 motor kit (Europe/USA)
50/60 Hz, 450/550 W, 1 phase 110-120/220-240 V
A654-99-000 A654-99-000
16
*
RV3/RV5 motor kit (Japan)
50/60 Hz, 250/300 W, 1 phase 100/200 V
A652-98-000 A652-98-000
17
*
RV8/RV12 motor kit (Japan)
50/60 Hz, 450/550 W, 1 phase 100/200 V
A654-98-000 A654-98-000
18 RV3/RV5 motor kit (Europe/USA/Japan)
50/60 Hz, 250/300 W, 3 phase 200-230/380-460 V
A652-97-000 A652-97-000
19 RV8/RV12 motor kit (Europe/USA/Japan)
50/60 Hz, 450/550 W, 3 phase 200-230/380-460 V
A654-97-000 A654-97-000
20 Oil pump kit RV3/RV5/RV8/RV12 A652-01-805 A652-01-805
21 Clean and overhaul kit (Nitrile) A652-01-137
22 RV3/RV5/RV8 and RV12 Motor kit (Europe/USA) 50/60 Hz,
450/550 W, 1-phase 220-240/ 230-240 V
A652-99-500 A652-99-500
23 RV3/RV5/RV8 and RV12 Motor kit (Japan) 50/60 Hz, 450/
550 W, 1-phase 100-200/ 200-210 V
A652-98-500 A652-98-500
24 RV voltage switch kit NXC7-56-001 NXC7-56-001
25 RV 3-phase voltage switch set A210-01-981 A210-01-981
26 Voltage label-200V-small pk 10 A200-02-776 A200-02-776

Edwards RV3 Specifications

General

Brand	Edwards
Model	RV3
Category	Water Pump
Language	English