Section 3-3 - Routine Maintenance
Service Schedules - Machines with SE Engines
Introduction
3-3-2 3-3-2
9803/3750-05 (3-21-00)
Introduction
A badly maintained machine is a danger to the operator
and the people working around him. Make sure that the
regular maintenance and lubrication jobs listed in the
service schedules are done to keep the machine in a safe
and efficient working condition.
!MWARNING
Maintenance must be done only by suitably qualified
and competent persons.
Before doing any maintenance make sure the machine
is safe, it should be correctly parked on level ground.
To prevent anyone starting the engine, remove the
starter key. Disconnect the battery when you are not
using electrical power. If you do not take these
precautions you could be killed or injured.
8-3-1-1
Apart from the daily jobs, the schedules are based on
machine running hours. Keep a regular check on the
hourmeter readings to correctly gauge service intervals.
Do not use a machine which is due for a service. Make
sure any defects found during the regular maintenance
checks are rectified immediately.
Calendar Equivalents
Note: Services should be carried out at either the hourly
interval or calendar interval, whichever occurs first.
How to Use the Service Schedules
In the example shown, A shows all service requirements to
be carried out every 10 hours and B shows the
requirements to be carried out every 500 hours.
Important: Services should be carried out at either the
hourly interval or calendar interval, whichever occurs first.
Refer to K
Calendar Equivalents ( T 3-3-2)
Fig 1.
Fuel System
Important: B20 Biodiesel must only be used in engines
built after January 2007 only.
If Biodiesel fuel is used there are additional service
procedures which must be carried out to prevent engine
damage. Failure to adhere to these additional procedures
may invalidate the warranty.
For these additional procedures see K
Related
Topics ( T 3-3-1)
SE Engines
In addition to the general safety notices and general good
workshop practices issued in this section and throughout
the manual, there are specific points to note when
completing maintenance on SE engine equipment. Refer
to K
Related Topics ( T 3-3-1)
Calendar equivalents:
Every 10 Hours = Daily
Every 50 Hours = Weekly
Every 500 Hours = Six Months
Every 1000 Hours = Yearly
Every 2000 Hours = 2 Years
Every 8000 Hours = 8 Years
ProCarManuals.com
To Next Page
Loading...
Need help?
General
