TP-6391 9/08 9Introduction
Introduction
This manual provides troubleshooting and repair
instructions for the generator set models listed on the
front cover.
For engine service procedures not covered in this
manual, refer to the Engine Service Manual listed below.
Information in this publication represents data available
at the time of print. Kohler Co. reserves the right to
change this publication and the products represented
without notice and without any obligation or liability
whatsoever.
Read this manual and carefully follow all procedures
and safety precautions to ensure proper equipment
operation and to avoid bodily injury. Read and follow the
Safety Precautions and Instructions section at the
beginning of this manual. Keep this manual with the
equipment for future reference.
The equipment service requirements are very important
to safe and efficient operation. Inspect the parts often
and perform required service at the prescribed intervals.
Maintenance work must be performed by appropriately
skilled and suitably trained maintenance personnel
familiar with generator set operation and service.
List of Related Materials
Separate manuals contain operation, installation, and
parts information not provided in this manual. Separate
engine Operation and Service manuals are also
available. The following table lists the available manual
part numbers.
Literature Type Part Number
Installation Manual TP-5982
Operation Manual (Generator) TP-6390
Operation Manual (Engine) TP-6001
Parts Catalog* TP-5987
Service Manual (Generator) TP-6391
Service Manual (Engine) TP-6002
Service Manual Supplement (Engine) TP-6008
* One manual combines Generator and Engine information.
Figure 1 Generator Set Literature
Routine Service Parts
The following table contains part numbers for
recommended spare parts. Contact your Kohler
generator distributor/dealer for a complete list of service
parts for your generator set or for models or spec
numbers not listed.
Part Description Part Number
Backfire flame arrestor GM24212
Fuse, (F1) 10 amp,
Auxiliary Winding
358337
Fuse, (F2) 10 amp,
Controller
223316
Fuse, (F3) 10 amp,
Customer Connection
223316
Fuse, (F4) 15 amp,
Coils/Injectors
283645
Fuse, (F5) 15 amp,
ECM, O
2
Sensor, and Fuel Pumps
283645
Fuse, (F6) 15 amp,
Voltage Regulator and Battery Charging
Alternator
283645
Fuse, (F7) 20 amp,
Starter Motor and Crank Solenoid
GM39266
Oil Filter 359771
Seawater Pump Impeller Kit 359978
Spark Plug GM46180
Spray Paint (White) 221335
Zinc Anode 260085
Figure 2 Maintenance and Service Parts
To Next Page
Loading...
Need help?
General
