Lennox EDV4035CPM-B User Manual

2
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
INTRODUCTION
The fireplace models covered in this manual
are direct-vent sealed combustion gas fireplace
heaters designed for residential application.
These direct-vent appliances operate with the
combustion chamber completely isolated from
the indoor environment.
All air for combustion is brought in from the
outside and exhaust gases are vented through
the same direct-vent, co-axial (intake/exhaust)
vent system.
The Millivolt appliances have a millivolt gas
control valve with piezo ignition system. If any
optional accessories which require electrical
power are being installed, the electrical power
must be provided at the time of appliance
installation.
The Electronic appliances are designed to
operate on either natural or propane gas. An
electronic intermittent pilot system provides
safe, efficient operation. External electrical
power is required to operate these units.
These appliances comply with National Safety
Standards and are tested and listed by OMNI-
Test Laboratories, Inc. (Report No. 116-F-05-5)
to ANSI ZZ21.88 (in Canada, CSA-2.33), and
CAN/CGA-2.17-M91 in both USA and Canada,
as vented gas fireplace heaters.
The Installation must conform to local codes
or, in the absence of local codes, with the
National Fuel Gas Code, ANSI Z223.1/NFPA
54-latest edition, or the Natural Gas and Pro-
pane Installation Code, CAN/CSA B149.1-latest
edition. The appliance, when installed, must be
electrically grounded in accordance with local
codes or, in the absence of local codes, the
latest edition of the National Electrical Code,
ANSI/NFPA 70, or the Canadian Electrical Code,
CSA C22.1 - latest editions.
CONGRATULATIONS!
In selecting this Lennox Hearth Products direct-vent gas appliance you have chosen the
finest and most dependable fireplace to be found anywhere. It is a beautiful, prestigious
alternative to a wood burning fireplace. Welcome to a family of tens of thousands of
satisfied Lennox Hearth Products fireplace owners.
Please carefully read and follow all of the instructions found in this manual. Please pay
special attention to the safety instructions provided in this manual. The care and opera-
tion instructions included here will assure that you have many years of dependable and
enjoyable service from your Lennox Hearth Products fireplace.
WARNING
Improper installation, adjust-
ment, alteration, service or
maintenance can cause injury
or property damage. Refer to
this manual. For assistance or
additional information consult
a qualified installer, service
agency or the gas supplier.
AVERTISSEMENT
Les enfants et les adultes
devraient être infor-més des
dangers que posent les tempéra-
tures de surface élevées et se
tenir à distance afin d’éviter des
brûlures ou que leurs vêtements
ne s’enflamment.
WARNING
Clothing or other flammable
material should not be placed
on or near the appliance.
AVERTISSEMENT
On ne devrait pas placer de
vêtements ni d’autres matières
inflammables sur l’appareil ni
à proximité.
WARNING
Children and adults should be
alerted to the hazards of high
surface temperature and should
stay away to avoid burns or
clothing ignition.
GENERAL INFORMATION
DO NOT ATTEMPT TO ALTER OR MODIFY
THE CONSTRUCTION OF THE APPLIANCE
OR ITS COMPONENTS. ANY MODIFICA-
TION OR ALTERATION MAY VOID THE
WARRANTY, CERTIFICATION AND LIST-
INGS OF THIS UNIT.
This manual is part of a set of two supporting
this product. Refer to manual 850,017M for
Installation Instructions.
TABLE OF CONTENTS
Introduction ......................................Page 2
General Information ..........................Page 2
Operation/Care of Your Appliance .....Page 5
Gas Controls Access .........................Page 5
Variable Flame Adjustment ................Page 6
Attaching Safety in
Operation Warnings ......................Page 7
Maintenance ......................................Page 8
Front Glass Enclosure Panel,
Removal and Installation .................Page 9
Install Volcanic Stone,
Embers and Logs ...........................Page 10
Burner Flame Appearance/Sooting ....Page 13
Burner Flame Adjustments ................Page 14
Millivolt Appliance Checkout .............Page 14
Electronic Appliance Checkout ..........Page 14
Warranty ...........................................Page 15
Wiring Diagrams ...............................Page 15
Replacement Parts ............................Page 15
Product Reference Information .........Page 15
Accessory Components ....................Page 16
Maintenance Schedule ......................Page 21
Lighting Instructions – Millivolt ........Page 22
Lighting Instructions – Electronic .....Page 24
Troubleshooting Guide – Millivolt......Page 26
Troubleshooting Guide – Electronic ..Page 27
Replacement Parts List .....................Page 28
Order Parts at: PartsFor.com or 866-607-2787
Order Parts at: PartsFor.com or 866-607-2787

Lennox EDV4035CPM-B Specifications

General

Brand	Lennox
Model	EDV4035CPM-B
Category	Indoor Fireplace
Language	English