Home
Mercury
Outboard Motor
4-STROKE
Mercury 4-STROKE User Manual
5
of 1
of 1 rating
131 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
TILTING OPERATION
To tilt the outboard, shut off the engine and press the tilt switch to the up
position. The outboard will tilt up until the switch is released or it reaches its
maximum tilt position. Tiller handle models have a kicker strap located on each
side of the outboard, preventing the outboard from turning when tilted up.
4676
38581
1.
Engage the tilt support lever by rotating lever down.
2.
Lower the outboard to rest on the tilt support lever.
FEATURES AND CONTROLS
eng
59
68
70
Table of Contents
Epa Emissions Regulations
5
Table of Contents
7
Warranty Registration United States and Canada
11
Transfer of Warranty United States and Canada
11
Warranty Information
11
Transfer of Mercury Product Protection (Extended Service Coverage) Plan United States and Canada
12
Year Limited Warranty against Corrosion
12
Warranty Coverage and Exclusions
15
U.S. EPA Emissions Limited Warranty
16
Emission Control System Components
16
California Emissions Limited Warranty
17
California Air Resources Board Explanation of Your California Emission Control Warranty Statement
20
Emission Certification Star Label
20
Warranty Policy-Australia and New Zealand
21
Global Warranty Charts Outboard and Jets
26
Boater's Responsibilities
31
Before Operating Your Outboard
31
Boat Horsepower Capacity
31
General Information
31
High-Speed and High-Performance Boat Operation
32
Outboard Remote Control Models
32
Remote Steering Notice
33
Lanyard Stop Switch
33
Protecting People in the Water
36
Passenger Safety Message - Pontoon Boats and Deck Boats
36
Wave and Wake Jumping
38
Impact with Underwater Hazards
39
Exhaust Emissions
40
Selecting Accessories for Your Outboard
42
Safe Boating Recommendations
42
Recording Serial Number
45
8/9.9 Fourstroke Specifications
45
Component Identification - Standard Models
47
Component Identification - Command Thrust/Prokicker Models
50
Transporting
51
Carrying, Storing, and Transporting Your Outboard When Removed from Boat
51
Trailering Boat/Outboard - Models with Power Tilt
52
Trailering Boat/Outboard - Models Without Power Tilt
52
Fuel Recommendations
54
Fuel and Oil
54
Low Permeation Fuel Hose Requirement
55
EPA Pressurized Portable Fuel Tank Requirements
55
Fuel Demand Valve (FDV) Requirement
55
Mercury Marine's Pressurized Portable Fuel Tank
56
Filling Fuel Tank
57
Engine Oil Recommendations
57
Checking Engine Oil
58
Tiller Handle Features
60
Features and Controls
60
Remote Control Features
66
Warning System
67
Power Tilt (if Equipped)
68
Setting the Transom Angle of Your Outboard
70
Adjusting Transom Angle
72
Shallow Water Operation
72
Tilting Outboard
73
Trim Tab Adjustment
74
Prestarting Check List
75
Operating in Freezing Temperatures
75
Operating in Saltwater or Polluted Water
75
Operation
75
Operating Outboard as an Auxiliary Engine
76
Prestarting Instructions
76
Engine Break-In Procedure
77
Starting the Engine - Tiller Handle Models
77
Starting the Engine - Remote Control Models
80
Starting a Hot Engine
82
Gear Shifting
82
Stopping the Engine
83
Emergency Starting
84
Outboard Care
87
EPA Emission Regulations
87
Inspection and Maintenance Schedule
88
Flushing the Cooling System
90
Top Cowl Removal and Installation
92
Battery Inspection
92
Exterior Care
92
Fuel System
93
Steering Link Rod Fasteners
93
Corrosion Control Anode
95
Propeller Replacement
95
Fuse Replacement - Electric Start Models
97
Spark Plug Inspection and Replacement
98
Timing Belt Inspection
99
Changing Engine Oil
99
Lubrication Points
101
Gearcase Lubrication
103
Checking Power Tilt Fluid
105
Submerged Outboard
106
Storage Preparation
107
Protecting External Outboard Components
107
Storage
107
Protecting Internal Engine Components
108
Gearcase
108
Positioning Outboard for Storage
108
Battery Storage
109
Starter Motor will Not Crank the Engine (Electric Start Models)
110
Engine will Not Start
110
Engine Runs Erratically
110
Troubleshooting
110
Performance Loss
111
Battery will Not Hold Charge
111
Service Assistance
112
Owner Service Assistance
112
Ordering Literature
114
Boat Horsepower Capacity
116
Start in Gear Protection
116
Selecting Accessories for Your Outboard
116
Installation
116
Low Permeation Fuel Hose Requirement
117
Installing Outboard
117
Remote Control Installation
120
Steering Link Rod Fasteners
120
Remote Wire Harness Connection
122
Control Cable Installation
124
Battery Installation - Electric Start Models
128
Battery Connections
129
Propeller Installation
129
Maintenance Log
131
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mercury 4-STROKE and is the answer not in the manual?
Ask a question
Mercury 4-STROKE Specifications
General
Brand
Mercury
Model
4-STROKE
Category
Outboard Motor
Language
English
Related product manuals
Mercury 4 4-Stroke
50 pages
Mercury 5 4-Stroke
50 pages
Mercury 6 4-Stroke
50 pages
Mercury 25 4-Stroke
72 pages
Mercury 40 4-Stroke
93 pages
Mercury 50 4-Stroke
134 pages
Mercury 90 4-stroke
31 pages
Mercury 60 4-Stroke
134 pages
Mercury 4-Stroke 9.9 HP
6 pages
Mercury 4.5
69 pages
Mercury 4 SERIES
260 pages
Mercury 4 TwoStroke
68 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
