60
MAINTENANCE
Periodic Maintenance Chart
Perform all services at whichever maintenance interval is reached first.
► Perform these procedures more often for vehicles subjected to severe use.
E Emission-Related Service.
D Have an authorized POLARIS dealer perform these services.
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Calendar Miles (Km)
Steering
Pre-Ride Make adjustments as needed.
See Pre-Ride Checklist on page 36.
Front suspension
Rear suspension
Tires
Brake fluid level
Brake pedal travel
Brake system
Wheels/fasteners
Frame fasteners
Engine oil level
►
E
Air filter, pre-filter - Daily - Inspect; clean often; replace as needed
Coolant - Daily - Check level
► Power steering unit (if equipped) - Daily - Inspect daily; clean often
Headlamp/tail lamp - Daily - Check operation; apply dielectric
grease to electrical connections if
replacing lamps
►
E
Air filter - Weekly - Inspect; replace as needed
►
D
Brake pad wear 10 H Monthly - Inspect periodically
Battery 20 H Monthly - Check terminals; clean; test
Fuel System 20 H Monthly - Inspect; cycle key to pressurize fuel
pump; check lines and fittings for leaks
and abrasion
►
E
Engine breather 25 H 1 M - Inspect; replace as needed
► Front Gearcase oil (if equipped) 25 H 1 M - Perform a break-in oil level check
► Middle Gearcase oil (if equipped) 25 H 1 M - Perform a break-in oil level check
► Rear gearcase oil (if equipped) 25 H 1 M - Perform a break-in oil level check
► Transmission oil 25 H 1 M - Perform a break-in oil level check
► Engine oil change (break-in) 25 H 1 M - Perform a break-in oil change at one
month
► General lubrication 50 H 3 M - Lubricate all fittings, pivots, cables, etc.
Shift Linkage 50 H 6 M - Inspect, lubricate, adjust
D Steering 50 H 6 M - Lubricate
► Front Suspension 50 H 6 M - Lubricate
► Rear Suspension 50 H 6 M - Lubricate
D
E
Throttle cable/Release switch 50 H 6 M 500 (800) Inspect; adjust; lubricate; replace if
necessary
E Throttle body air intake ducts/
flange
50 H 6 M 500 (800) Inspect duct for proper sealing/air leaks
Drive belt 50 H 6 M 500 (800) Inspect; adjust; replace as needed
To Next Page
Loading...
Need help?
General
