58
ENGINE OIL FILTER
The engine oil filter must be changed by an
authorized Suzuki Marine Dealer periodically.
Replace engine oil filter with a new one at initial
20 hours (1 month).
Replace engine oil filter with a new one at every
200 hours (12 months).
FUEL FILTER
The fuel filter must be inspected by authorized
Suzuki Marine Dealer periodically.
Low pressure fuel filter
Inspect low pressure fuel filter at initial 20 hours
(1 month).
Inspect low pressure fuel filter at every 100
hours (12 months).
Replace low pressure fuel filter with a new one
at every 400 hours (2 years).
TIMING BELT
The timing belt must be changed by authorized
Suzuki Marine Dealer periodically.
Inspect timing belt at every 200 hours (12
months).
Replace timing belt with a new one at every 4
years.
FLUSHING THE WATER
PASSAGES
After operation in muddy, brackish, or salt
water, you should flush the water passages and
motor surface with clean, fresh water.
If you do not flush the water passages, salt can
corrode the motor and shorten its life. Flush the
water passages as follows.
ENGINE RUNNING – Vertical position –
Suzuki recommends that you flush the water
passages using this method.
To flush the water passages, you must obtain a
commercially available engine flush device.
WARNING
Exhaust gas contains carbon monoxide, a
dangerous gas that is difficult to detect
because it is colorless and odorless. Breath-
ing carbon monoxide can cause death or
severe injury.
Never start the engine or let it run indoors or
where there is little or no ventilation.
WARNING
Failure to take proper precautions when flush-
ing the water passages can be hazardous.
When flushing the water passages, always
take the following precautions:
• Make sure that the engine remains in NEU-
TRAL. If shifted into gear, the propeller
shaft will turn and could cause severe per-
sonal injury.
• Make sure the motor is properly clamped to
a secure stand or boat, and remain in atten-
dance until flushing is completed.
• Keep children and pets away from the area,
and stay clear of all moving parts.
To Next Page
Loading...
Need help?
General
