Tomahawk TPS25 Operations & Parts Manual

9
6.Safe Operation
6.1 Read the instruction manual carefully.
6.2 Protective gear:
a ) Wear a flanged cap
b ) Wear dirt/fog-proof goggles
) Wear a gauze mask
) Wear a coat guard
c
d
e ) Wear long sleeve gloves
f ) Wear boots
7.Troubles hooting
7.1 Engine troubleshooting guide
Problem Cause Remedy
Fails to start Fail to push the fuel-injecting pump Push continuously
Water mixed with fuel Replace the fuel
Deterioration or carbon deposit of spark plug Replace the plug
Bad contact between spark plug and lead
wire
Check spark plug
It starts but cannot run at high speed The choke is not on the full open position Open to full
position
Wrong ratio of fuel Replace
Water in fuel Replace the fuel
It runs but does not work efficiently The air filter is dirty Check and clean
Outlet of cylinder and muffler are dirty Remove the dirt
Piston, piston ring, cylinder have been worn Replace
Stops while running Fuel is out Add fuel
The lead wire of plug is loose Check and replace
Plug covered with carbon Replace the plug
The filter is clogged Clean
Water in fuel Replace fuel
The air hole in the tank lid is clogged Clean

Tomahawk TPS25 Specifications

General

Brand	Tomahawk
Model	TPS25
Category	Paint Sprayer
Language	English