4
• Never remove gas cap or add fuel with engine
running. Allow engine to cool before refueling.
Do not smoke.
• Never refuel or drain the aerator indoors.
• Check that operator’s presence controls, safety
switches and shields are attached and functioning
properly. Do not operate unless they are functioning
properly.
Operation
• Never run an engine in an enclosed area.
• Only operate in good light, keeping away from holes
and hidden hazards.
• Be sure all drives are in neutral and parking brake is
engaged before starting engine. Start the engine only
from the operator’s position.
• Never operate without the shields, covers or other
guards securely in place. Be sure all interlocks are
functioning properly.
• Do not change the engine governor setting or
overspeed the engine.
• Stop on level ground, raise coring head, disengage
drives, engage parking brake, shut off engine before
leaving the operator’s position for any reason.
• Stop equipment and inspect tines after striking objects
or if an abnormal vibration occurs. Make necessary
repairs before resuming operations.
• Keep hands and feet away from the tine area.
• Never carry passengers and keep pets and bystanders
away.
• Be alert, slow down and use caution when making
turns. Look behind and to the side before changing
directions.
• Slow down and use caution when crossing roads and
sidewalks.
• Do not operate the aerator under the influence of
alcohol or drugs.
• Use extreme care when loading or unloading the
aerator into a trailer or truck.
• Use care when approaching blind corners, shrubs,
trees, or other objects that may obscure vision.
Slope Operation
• Do not operate near drop–offs, ditches, steep banks or
water. Wheels dropping over edges can cause
rollovers, which may result in serious injury or death.
• Do not operate on slopes when grass is wet. Slippery
conditions reduce traction and could cause sliding and
loss of control.
• Do not make sudden turns or rapid speed changes.
• Reduce speed and use extreme caution on slopes.
• Remove or mark obstacles such as rocks, tree limbs,
etc. from the operating area. Tall grass can hide
obstacles.
• Watch for ditches, holes, rocks, dips, and rises that
change the operating angle, as rough terrain could
overturn the aerator.
• Be aware that loss of traction may occur going
downhill. Weight transfer to the front wheel may cause
drive wheels to slip and cause loss of braking and
steering.
• Always avoid sudden starting or stopping on a slope. If
tires lose traction, disengage the tines and proceed
slowly off the slope.
• Follow the manufacturer’s recommendations for wheel
weights or counterweights to improve stability.
Maintenance and storage
• Wait for all movement to stop before adjusting,
cleaning or repairing. Disengage tines, raise coring
head, set parking brake, stop engine and remove key.
• Clean grass and debris from tines, drives, mufflers, and
engine to help prevent fires. Clean up oil or fuel
spillage.
• Let engine cool before storing and do not store near
flame.
• Shut off fuel while storing or transporting on trailers.
Do not store fuel near flames or drain indoors.
• Park aerator on level, hard ground. Never allow
untrained personnel to service aerator.
• Use jack stands or safety latches to support
components when required.
• Carefully release pressure from components with
stored energy.
• Disconnect battery or remove spark plug wire before
making any repairs. Disconnect the negative terminal
first and the positive last. Reconnect positive first and
negative last.
• Keep hands and feet away from moving parts. If
possible, do not make adjustments with the engine
running.
• Charge batteries in an open well ventilated area, away
from spark and flames. Unplug charger before
connecting or disconnecting from battery. Wear
protective clothing and use insulated tools.
To Next Page
Loading...
Need help?
General
