4.3GXi-J
ENGINE
Bore and stroke . . . . . . . . . . . . . .
Cylinders (number) . . . . . . . . . . .
Displacement . . . . . . . . . . . . . .
Firing order . . . . . . . . . . . . . . .
Full throttle operating range . . .
Idle RPM . . . . . . . . . . . . . . . . . . .
4.000 x 3.480 in. (101.60 x 88.39 mm)
90° V-8
262 Cu. In. (4.3 liters)
1 – 6 – 5 – 4 – 3 – 2
4400 – 4800 RPM
600 RPM in forward gear
FUEL SYSTEM
Fuel injection . . . . . . . . . . . . . . . .
Fuel pumps . . . . . . . . . . . . . . .
Fuel filter . . . . . . . . . . . . . . . . .
Fuel type . . . . . . . . . . . . . . . . . .
Port injection
Electric
Volvo Penta, water separating, spin-on filter or can
See Gasoline Requirements in this section
ELECTRICAL SYSTEM
Charging system . . . . . . . . . . .
Starter . . . . . . . . . . . . . . . . . . .
Battery size . . . . . . . . . . . . . . . .
12 volt 75 amp alternator, with internal transistorized voltage regulator
12 volt 1.7kW output, planetary reduction gear
12 volt with 650 Cold Cranking Amp (CCA) rating (135 minute reserve capacity)
Do not use a deep cycle battery as the start battery
IGNITION SYSTEM
Distributor . . . . . . . . . . . . . . . .
Ignition Timing. . . . . . . . . . . . .
Spark plugs . . . . . . . . . . . . . . .
Spark plug gap . . . . . . . . . . . . . . .
Spark plug installation torque .
Delco EST
10° BTDC Fixed
See Tune-up and Color Code Decal on engine cover or Parts Catalog
0.060 inches (1.50 mm)
20 ft. lb. (27 Nm)
COOLING SYSTEM
Raw water pump . . . . . . . . . . .
Recirculating pump . . . . . . . . . . .
Thermostat . . . . . . . . . . . . . . . .
Crankshaft mounted variable volume flexible impeller pump
Fixed impeller belt driven pump on engine
150°F (66°C)
OIL FILTER
Engine oil filter . . . . . . . . . . . . . Volvo Penta, replaceable paper element
OIL CAPACITY
NOTICE! Overfilling the oil can cause engine and/or sterndrive damage. We urge you to use the dipstick to check
the oil level whenever you are changing or topping up the oil.
Engine with filter . . . . . . . . . . . . .
Drive unit . . . . . . . . . . . . . . . . .
4.0 quarts (3.8 liters)
See Sterndrive: Drive Components in this section
OIL TYPE
Engine . . . . . . . . . . . . . . . . . . .
Drive unit . . . . . . . . . . . . . . . . .
Power steering fluid U.S . . . . . .
Power steering fluid non-U.S . .
See Engine Oil Specifications in this section
See Sterndrive: Drive Components in this section
Volvo Penta power steering fluid
ATF oil Dexron 2 or higher classification
OIL PRESSURE (MINIMUM)
@ 1000 RPM . . . . . . . . . . . . . .
@ 2000 RPM . . . . . . . . . . . . . .
@ 4000 RPM . . . . . . . . . . . . . .
6 PSI (41 kPa)
18 PSI (124 kPa)
24 PSI (166 kPa)
Technical Data
47700385 05-2009 99
To Next Page
Loading...
Need help?
General
