To Next Page

To Previous Page

Trouble Shoong Guide:

BURNER WILL NOT LIGHT:

1. Gas supply is turned o. Turn on at gas and LP tank

2. Out of fuel. Check tank to be sure

3. Regulator is not properly sealed with tank. Remove and reaach. Hand ghten only

4. Crimped fuel supply hose. Inspect and straighten

5. Regulator failure or damaged hose. Replace as needed

6. Igniter failure. Ensure igniter clicks when acvated. If not, do the following:

a. Inspect and replace “AA” baery

b. Inspect electrode and clean with alcohol

c. Adjust distance between electrode and burner between 1/4” to 1/8”

d. Inspect electrode for cracks; replace if needed

7. Gas system blockage. Inspect for insects, spider webs, etc. Clean as needed. Ensure burners

are aligned properly with valves

IRREGULAR FLAME OR YELLOW FLAME:

1. New burner may have residual oil, which will burn o

2. Burner tubes are blocked; remove and clean

3. Burners have grease or dirt build-up; remove and clean

4. Burners not aligned with valves; inspect and correct

SUDDEN DROP IN GAS PRESSURE OR FLAME BLOW OUT:

1. Out of gas; check cylinder for gas levels

2. Excessive ow valve has tripped and reduced gas ow

a. Turn o gas and wait 30 seconds

b. Disconnect regulator from tank and wait 10 minutes

c. Check hose for ruptures and perform leak test

d. Open control knobs

e. Cylinder was improperly purged; contact gas dealer

3. Wind may blow out your burners; turn your grill

EXCESSIVE FLARE UPS:

1. Flame shield, grill interior, grates, and burners must be cleaned

2. Grease tray needs to be emped and cleaned

3. Heat is too high during cooking; reduce temperature

4. Direct cooking produces more are ups; use indirect more oen

FIRE BEHIND CONTROL PANEL:

1. Immediately turn o gas at cylinder and let grill cool

2. Inspect control panel to ensure burners and valves are aligned properly

3. Gas is leaking from hose or tank; perform leak test

Backyard PRO User Manual

Questions and Answers: