10
1/00
UNIT SAFETY
Rules of Operation
KNOW your Unit – before starting engine. Understand:
• How to operate all controls
• The functions of all controls
• How to STOP in an Emergency
• Speed ranges
Walk Around Inspection
Complete a walk around inspection of unit and work area
to understand:
• Work area
• Your unit
• All safety decals
Safety Interlock System
Check Safety Interlock System for proper operation daily
(see Operation section).
Clearances
ALWAYS check overhead and side clearances carefully
before operation.
ALWAYS be aware of traffic when operating along streets
or curbs. Set up safety signs and/or flags.
PERSONAL SAFETY
Responsible Operators
• Only trained adults may operate unit.
• Training includes actual operation.
• Clearly understand instructions.
• Be alert! Conditions can change.
Pre-Start
Before starting engine: disengage PTO and set parking
brake.
Hot Surfaces
DO NOT touch parts which are hot. Allow parts to cool.
Safety Covers
ALWAYS keep discharge cover or complete grass bagger
in place.
Replacement Parts
ALWAYS maintain unit in safe operating condition.
Damaged or worn out muffler can cause fire or explosion.
Clear Area
ALWAYS clear area before operation. Thrown objects can
cause injury.
Speed Ranges
DO NOT mow at too fast a rate. DO NOT change engine
governor settings or over speed the engine.
Avoid loss of control
Avoid uneven work areas and any rough terrain.
Thrown Objects
Disengage PTO when crossing hard surfaces and gravel
drives. Be aware of mower discharge direction and do not
point it at anyone.
Keep all safety covers:
• In place
• In proper working condition
Safety Gear
Wear adequate safety gear, protective gloves and
footwear. NEVER wear loose clothing, jewelry or long
hair that may get caught in rotating parts.
Protect eyes, face and head from objects that may be
thrown from unit.
OPERATIONAL SAFETY
Safe Distances
Keep children and people away from unit during
operation. Use care when approaching blind corners,
shrubs, trees or other objects that may obscure vision.
ALWAYS keep feet and hands away from all rotating
blades. Rotating parts can cut off body parts.
Starting
Start and operate unit only when seated in operator’s
position. Steering control levers must be in neutral, PTO
disengaged and parking brake set when starting engine.
Tip over
Avoid uneven, unstable and rough terrain. DO NOT
operate near drop offs, ditches, or embankments. Unit
can suddenly turn over if a wheel is over the edge of a
cliff or ditch, or if an edge caves in.
Reverse
ALWAYS backup slowly. ALWAYS look down and behind
before and while backing. Do not operate in reverse
unless absolutely necessary.
Load Capacity
Use care when pulling loads. Use only approved drawbar
hitch points. Limit loads to those you can safely control.
Traction
If tires lose traction, turn off PTO and proceed slowly
straight down slope. If you cannot back up the slope or
feel uneasy, do not mow it. Avoid mowing wet grass.
Parking Brake
Check brake operation frequently. Adjust and service as
required.
No Riders
Never carry passengers.
To Next Page
Loading...
Need help?
General
