601156_0110 4-3
Each transaxle’s filter is located per Fig. 4-2. A standard oil
filter wrench is used to change filter, threads are right handed.
Use a Hustler approved filter element only.
IMPORTANT: Purging procedures must be followed after
changing the oil and filter. Refer to Parts Manual (Hustler P/N
108277) for more detailed oil changing and purging informa-
tion.
WARNING: When washing the mower, direct the
spray away (especially if using a power washer) from
the Hydro-Gear ZT 2800 transaxle’s seals to prevent
water intrusion and to ensure component performance.
The FasTrak 36/42 (Mini FasTrak 36/42) is equipped with
two Hydro-Gear EZT integrated pump/motor
transmissions. Fig. 4-3
The EZT integrated pump/motor transmissions are sealed for
life and do not require any scheduled service.
WARNING: When washing the mower, direct the
spray away (especially if using a power washer) from
the Hydro-Gear EZT transmission’s seals to prevent
water intrusion and to ensure component performance.
Fuel system
DANGER: To avoid personal injury or property
damage, use extreme care in handling gasoline.
Gasoline is extremely flammable and the vapors
are explosive.
DANGER: Observe usual fuel handling precautions:
• Do not smoke while refueling. Extinguish all ciga-
rettes, cigars, pipes and other sources of ignition.
• Do not remove fuel cap or fill tank with engine run-
ning or while engine is hot. Clean up any gasoline
spills.
• Allow engine to cool before storing machine inside
a building.
• Keep fuel away from open flame or spark and store
machine away from open flame or spark or pilot
light such as on a water heater or other appliances.
• Use extreme care when handling gasoline and other
fuels. They are extremely flammable and vapors are
explosive. A fire or explosion from gasoline can
burn you and others and can damage property.
• Refuel outdoors. Never refuel or drain the fuel from
the machine indoors.
• Never attempt to start engine when there is a strong
odor of gasoline fumes present. Locate and correct
cause.
• Store gasoline in an approved container and keep it
out of the reach of children. Never buy more than a
30 day supply of gasoline.
• Do not fill gasoline containers inside a vehicle or on
a truck or trailer bed with interior carpets or plastic
truck bed liners. Always place gasoline containers
on the ground away from your vehicle before filling.
Fig. 4-1
Fig. 4-2
ZT 2800 transaxle
Expansion
tank
FasTrak 48/54 shown
Fig. 4-3
EZT Integrated
pump/motor
FasTrak 36/42 shown
To Next Page
Loading...
Need help?
General
