I / A
Every 100
Engine oil - Diesel.......................2.6 qt (2.5 liter)
R
R
R
(0.97 - 1.10 bar)
I
Universal
Reel Set-up
Clean Debris from Radiator
VI
I / C
Item
Radiator Screens
Check Safety Interlock Functions
Battery Fluid (Distilled Water)
L
Diesel
Muffler and Exhaust
I / A
SAE 10W30 (API Classification:SF, SG, SH, SJ or Higher) Initial oil change after 5 hours of operation then every 100 hours.
Fuel.............................................5.5 gal (20.82 liter)
Lubricant
I
Check Coolant Level
Hours
I
Seat Slide
Steering Chain
Hours
L
II
I / A
Grease Fittings - F3
Hours
Fuel Filter
L
I
I / A
10
Every 8-
C
C
Hours
50 Hours
Check Engine Oil Level
FLUID CAPACITIES
Grease Fittings - F2
Engine oil - Gasoline...................48 oz.(1.4 liter)
R
Every
Battery Terminals
SAE 30 Oil
Engine Oil Filter
R (VI)
I / C
Air Cleaner - Pre Cleaner
Air Cleaner
L
Check Entire Machine for Fluid Leaks
L
Check Reel Set-up
Check Tire Pressure
Not required unless engine performance problems occur.
Every 40- Every 500
I
Type
R (VI)
Electrical System
Wiring
SAE 10W30 (API Classification:CF, CF-4, CG-4, CH-4 or CI-4)
C
For additional service information please refer to the Parts and Maintenance Manual
Spark Plugs
Gas
I / C
II
Wiring Diagram
Model
Cooling System
Belts / Hoses
C
Fuel Filter
Fuel Lines and Clamps
R
A
VII
I / A
R
Every 200
R
II
I / C
IV
I / C
Engine Oil
Engine Oil Filter
Hours
Muffler and Exhaust
I / C
II
Hours
R
III
Every 400
R
I
Tires
Differential Oil
Rear Wheel Bearings
Electroyte
Brake Resistors
III
Check Valve Clearance
Pack bearings with NLGI Grade 2 (Service Class GB)
Replace after first 50 hours, then every 100 hours
I
I / L
II
I / A
I
Check Air Filter
I
Engine Oil
Every 25
I
VII
1000
Hours
C
Coolant - Diesel
..........................0.74 gal (2.8 liter)
Radiator Hoses
IV
Daily Checks
C
V
A - Add or Adjust C - Clean I - Inspect L - Lubricate R - Replace Ar - As Required
Grease Fittings - F1
Air Cleaner - Pleated Cartridge
V
Fuel Lines and Clamps
Manual grease gun with NLGI Grade 2 (Service Class LB)
Front and Rear Tire Pressure....14-16 psi
II
4225600
2X F2 (POWER BRUSH
IF EQUIPPED)
6X F2
6X F2 (GROOMER IF EQUIPPED)
F1 F1
2X F1
4X F5 SPRINGS
F5 CHAIN
2X F5 SPRINGS
F1
F1
Service
F1: every 50 hours pack bearings with NLGI Gr 2 (service class GB)
F2: every 100 hours manual grease gun with NLGI Gr 2 (service class LB)
F5: every 100 hours SAE 30 OIL
FW
If It's not Jacobsen,
it's not genuine.
When Performance Matters.
™
To Next Page
Loading...
Need help?
General
