LUBRICATION CHART
LUBRICATION
CHART
'
ODOMETER READING
ASSEMBLY
TYPE OF
Miles- 300 1200 2500 5000 6500 9000 12000
LUBRCATION Kms.;- 500 2000 4000 8500 10500 15000 20000
Gear Oil SAE 80 W 90 R R R R R R
Brake lever OKS-400 (Multi
gurpose Lithium
R R R
assembly
ase grease)
R R R
Disc brake,fluid DOT 3 or DOT4 R Replace once a year then after
Front fork oil Shocker oil I I I T I I I
.
Speedometer OKS-400 (Multi
gurpose Lithium
I R I
pinion
ase grease)
I R
OKS-400 (Multi
gurpose Lithium
I
Steering races
ase grease)
I
OKS-400 (Multi
gurpose Lithium
I R R
Wheel bearing
ase grease)
I R
OKS-400 (Multi
Brake actuating
gurpose Lithium
"
I
shaft ase grease)
I
Battery terminals Petroleum Grease I I I I I I I
I
-
INSPECT
R-REPLACE T- TOP UP
RECOMMENDATIONS FOR SAFE AND OPTIMUM VEHICLE PERFORMANCE
. Do not start the engine or use the vehicle without properly connecting the battery as this can severely damage electrical components.
. If the vehicle will not be used for a long time, disconnect the battery cable to avoid battery drainage. Check the battery every two weeks and charge
as necessary.
. For extended storage or "Hibernation" remove the battery from the vehicle and charge it to 100% on slow-charge for at least 24 hours. Charge the
battery every month if stored at temperatures below 60°F, charge every two weeks if stored in an area above 60°F. Make sure batteries are stored out
of reach of children.
. Store the battery in a cool, dry place away from direct sunlight.
RECOMMENDED CARBURETOR SETTING
Air screw IMixture screw setting procedure
Step1- Run the engine at normal operating temperature.
Step2- Adjust the engine rpm to 1800 +/- 1 00
Step3-Adjust the Air screw I Mixture screw 1,5 +/- 0,5 turns out (counter-clockwise)
Step4- Again adjust the engine rpm to 1800 +/- 1 00
SPARK PLUG COMPATIBILITY
BRAND TYPE
To Next Page
Loading...
Need help?
General
