KEEWAY HURRICANE User Manual

SERVICE
1 st SERVICE
600 miles / 1000 kms or 1 month
Odometer reading ………
Dealers stamp Date
2 nd SERVICE
1200 miles / 2000 kms or 3 months
Odorheter reading ………
Dealers stamp Date
3 rd SERVICE
2500 miles / 4000 kms or 5 months
Odometer reading……….
Dealers stamp Date
4 th SERVICE
4000 miles / 6500 kms or 7 months
Odometer readlng ………
Dealers stamp Date
5 th SERVICE
5000 miles / 8500 kms or 9 months
Odometer reading
Dealers stamp Date
6 th SERVICE
6500 miles / 10500 kms or 11 months
Odometerreading ………
Dealers stamp Date
IMPORTANT
PLEASE ENSURE THAT THE VEHICLE SERVICES ARE
PERFORMED AT SPECIFIED MENTIONED INTERVALS OF
MILEAGE OR WHICHEVER IS EARLIER. ALL SERVICES
SHOULD BE PERFORMED ONLY BY AUTHORIZED
KEEWAY DEALERS / SERVICE CENTERS
TROUBLE SHOOTING
TROUBLE SHOOTING
S.no.
COMPLAINT CAUSES REMEDIES
ENGINE
1 Startina Trouble PLUG NOT SPARKING
1. DamaQed Spark pluQ or spark plug cap Replace
2. Dirtv or wet spark clua Clean and adjust gap to O.5mm
3. Defective COl & lanition coil unit or stator coil Replace
4. Open or shorten high- tension cord Replace
5. Defective lanition Switch Replace
NO FUEL REACHING THE CARBURETOR
1. Clogged hole in the fuel tank cap Clean
2. Clogged or defective fuel pump Clean or replace
3. Defective Carburetor Raat valve Replace
4. Clogged fuel hose or defective vacuum hose Clean or replace
CARBURETOR
1. Starter jet is dogged Clean
2. PJr leaking from a joint between starter bodv and
carburetor
Check carburetor for tightness, replace
gasket
3. PJr leaking from carburetor' ioints or vacuum hose joint Check and replace
COMPRESSION TOO LOW
1. Excessively wom cylinder or piston rings Replace
2. Stiff piston ring in place Repair or replace
3. Gas leaks from the joint in crankcase, cylinder or cylinder
head
Repair or replace
4. Damaged reed valve Replace
5. Spark plug too loose Tighten
6. Broken, cracked or failed piston Replace
Engine starts 1. Carbon deposited on the spark plug Clean
2
but cuts off 2. Defective COl & Ignition coil unit Replace
3. Clogged fuel hose Clean
4. Clogged jets in carburetor Clean
5. Clogged exhaust pipe Clean
Rattling sound NOISE COMING FROM PISTON
3
from engine 1. Piston or cylinder wom down Replace
2. Combustion chamber filled with carbon Clean

KEEWAY HURRICANE Specifications

General

Brand	KEEWAY
Model	HURRICANE
Category	Scooter
Language	English