KEEWAY HURRICANE User Manual

ENGINE
3. Piston pin, billing or piston pin bore worn Replace
4.Piston rings or ring grooves worn Replace
NOISE COMING FROM CRANK SHAFT
1. Worn or burnt crankshaft bearings Replace
2. Worn or burlJtconrod big-end bearings Replace
NOISE COMING FROM FINAL GEAR BOX
1. Gears worn orrubbing Replace
2. Worn or damaged bearing of drive shaft or rear axle shaft Replace
4 Engi!le lacks power 1. Excessively worn cylinder or piston rings Replace
2. Stiff piston ring in place Replace
3. Gas leaks from crankshaft oil seal Replace
4. Spark plug gaps incorrect Adjust or replace
5. Clogged air cleaner element Clean
6. Float -Chamber fuel level out of adjustment Adjust or replace
7. Clogged air cleaner element Clean
8. Sucking air from intake pipe Retighten or replace
9. Slipping or worn V-belt Replace
10.Damaged / worn rollers in the movable drive face Replace
11. Weaken movable driven face spring Replace
12.Excessive fuel/air mixture due to defective starter system Replace
5 Engine overheats 1. Heavy carbon deposit on 'piston crown Clean
2. Defective oil pump of clogged oil circuit Replace and clean
3. Fuel level too lowjpfjpat chamber Adjust or replace
4. Air leakage frol]1intake pipe Retighten or replace
S.no.
COMPLAINT CAUSES REMEDIES
6. Use of improper spark plug Change
7. Clogged exhaust pipe/muffler Clean or replace
CARBURETOR
Idling or low-speed 1. Pilot jet, pilot air jet is clogged or loose Check and clean
1 troubles
2. Air leaking from carburetor's joint, vacuum pipe joint or
starter
Check and replace
CARBURETOR
3. Pilot ol!Uet is clogged Check and clean
4. Starter:plunger is not fully close Check and replace
2
Medium-or hinh sneed
trouble
1. Main jet or main air jet is clogged Check and clean
2. Needle jet is clogged Check and clean

KEEWAY HURRICANE Specifications

General

Brand	KEEWAY
Model	HURRICANE
Category	Scooter
Language	English