Kohler 16EKOZD User Manual

94 TP-7044 6/23
Section or Publication Reference*
Controller
W/D
Gen S/M
Operation Section
Operation Section, W/D, Gen, S/M
Operation Section
Controller Display and Voltage Regulation Troubleshooting Chart Section
 ATS - Automatic Transfer Switch; Eng.
- Engine; Gen.
- Generator Set; I/M
- Installation Manual; O/M
- Operation Manual; M/M
– Maintenance Manual; S/M
- Service Manual;
S/S - Spec Sheet; W/D
- Wiring Diagram Manual
† Have an authorized service distributor/d
ealer perform this service.
Recommended Actions
Check the wiring.
Troubleshoot the controller.†
Press the controller master control RUN or AUTO button.
Press the controller master control RU
N button to
test the
generator set. Troubleshoot
the auto start
circuit and the
time delays.
Reset the emergency stop switch.
Check the remote switch position.
Review the controller display troubleshooting chart.
Probable Causes
Controller circuit board(s) w
iring fault
.
Controller fault.
Controller master cont
rol button in
the OFF/RESET mode.
Engine start circuit open.
Emergency stop switch activated, if equipped.
Remote stop command received from a remote switch or ATS.
Controller firmware error.
Trouble Symptoms
Exercise run time
and/or event records
inoperative
Displays error
message/locks up
X
Excessive or abnormal
noise
High fuel consumption
Low oil pressure
Overheats
Lacks power
Stops suddenly
X
X
X
No or low output voltage
Starts hard
Cranks but does not
start
X
Does not crank
X
X
X
X

Kohler 16EKOZD Specifications

General

Brand	Kohler
Model	16EKOZD
Category	Portable Generator
Language	English