TROUBLESHOOTING
103
Starter Motor Will Not Crank the Engine (Electric
Start Models)
POSSIBLE CAUSES
• Blown 20 amp fuse in the starting circuit. Refer to
Maintenance section.
• Outboard is not shifted to neutral position.
• Weak battery or battery connections are loose or corroded.
• Ignition key switch/start button failure.
• Wiring or electrical connection faulty.
• Starter motor or starter solenoid failure.
Engine Will Not Start
POSSIBLE CAUSES
• Lanyard stop switch not in "RUN" position.
• Battery not fully charged.
• Incorrect starting procedure. Refer to Operation section.
• Old or contaminated fuel.
• Fuel is not reaching the engine.
• Fuel tank is empty.
• Fuel tank vent not open or restricted.
• Fuel line is disconnected or kinked.
• Primer bulb not squeezed.
• Primer bulb check valve is faulty.
• Fuel filter is obstructed. Refer to Maintenance section.
• Fuel pump failure.
• Fuel tank filter obstructed.
• Ignition system component failure.
• Spark plugs fouled or defective. Refer to Maintenance
section.
Engine Runs Erratically
POSSIBLE CAUSES
• Low oil pressure. Check oil level.
To Next Page
Loading...
Need help?
General
