Home
Mercury
Boat
200 OptiMax DTS
Mercury 200 OptiMax DTS User Manual
4
of 1
of 1 rating
157 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
TROUBLESHOOTING
eng
141
•
Low electrolyte level in battery.
•
Worn out or inefficient battery.
•
Excessive use of electrical accessories.
•
Defective rectifier, alternator, or voltage regulator.
•
Open circuit in the alternator output wire (fused link).
152
154
Table of Contents
Table of Contents
7
Warranty Registration
13
Warranty Information
13
Transfer of Warranty
14
Transfer of Mercury Product Protection (Extended Service Coverage) Plan United States and Canada
14
Outboard Limited Warranty
15
Year Limited Warranty against Corrosion
19
Warranty Coverage and Exclusions
23
U.S. EPA Emissions Limited Warranty
25
Emission Control System Components
25
California Emissions Limited Warranty
26
California Air Resources Board Explanation of Your California Emission Control Warranty Statement
30
Emission Certification Star Label
31
Boater's Responsibilities
33
Before Operating Your Outboard
33
General Information
33
Boat Horsepower Capacity
34
High-Speed and High-Performance Boat Operation
34
Outboard Remote Control Models
35
Propeller Selection
35
Remote Steering Notice
38
Lanyard Stop Switch
39
Protecting People in the Water
42
Passenger Safety Message - Pontoon Boats and Deck Boats
43
Wave and Wake Jumping
44
Impact with Underwater Hazards
45
Exhaust Emissions
47
Selecting Accessories for Your Outboard
49
Safe Boating Suggestions
49
Recording Serial Number
51
200/225 Optimax DTS Specifications
51
Component Identification
53
Installing Outboard
54
Propeller Selection
55
Trailering Boat/Outboard
57
Transporting
57
Fuel Recommendations
58
Fuel and Oil
58
Fuel Additives
60
Fuel Requirements
60
Avoiding Fuel Flow Restriction
60
Low Permeation Fuel Hose Requirement
60
EPA Pressurized Portable Fuel Tank Requirements
60
Fuel Demand Valve (FDV) Requirement
61
Mercury Marine's Pressurized Portable Fuel Tank
61
Filling Fuel Tank
63
Oil Recommendation
63
Filling Remote Oil Tank
63
Filling Engine Mounted Oil Reservoir Tank
64
Panel Mount Control Features and Operation
65
Features and Controls
65
Single Handle Console Control Features and Operation
68
Slim Binnacle Control Features and Operation
73
Dual Handle Console Control Features and Operation
77
Dual Handle Console Control with CAN Trackpad Features and Operation
82
Shadow Mode Control Features and Operation
87
Shadow Mode Control with CAN Trackpad Features and Operation
95
Warning System
104
Power Trim and Tilt
107
Pre-Starting Check List
112
Operating in Freezing Temperatures
112
Operation
112
Operating in Saltwater or Polluted Water
113
Operating at High Elevations
113
Setting Trim Angle While Running Engine at Idle Speed
113
Engine Break-In Procedure
114
Starting the Engine
115
Gear Shifting
118
Stopping the Engine
119
Outboard Care
120
EPA Emissions Regulations
120
Inspection and Maintenance Schedule
121
Flushing the Cooling System
123
Top Cowl Removal and Installation
124
Cleaning Care for Top Cowl
124
Alternator Belt Inspection
125
Fuel System
125
Steering Link Rod Fasteners
128
Fuse Replacement
130
DTS Wiring System
131
Corrosion Control Anode
131
Battery Inspection
132
Battery Information
133
Propeller Replacement
134
Spark Plug Inspection and Replacement
137
Compressor Air Intake Filter
138
Lubrication Points
140
Checking Power Trim Fluid
144
Gearcase Lubrication
145
Submerged Outboard
146
Storage Preparation
147
Fuel System
147
Protecting Internal Engine Components
149
Protecting External Outboard Components
149
Gearcase
150
Positioning Outboard for Storage
150
Battery Storage
150
Starter Motor will Not Crank the Engine
151
Engine will Not Start
151
Troubleshooting
151
Engine Starts but will Not Shift into Gear
152
Engine Runs Erratically
152
Performance Loss
152
Battery will Not Hold Charge
152
Local Repair Service
154
Service Away from Home
154
Parts and Accessories Inquiries
154
Service Assistance
154
Owner Service Assistance
154
Mercury Marine Service Offices
155
Maintenance Log
157
Other manuals for Mercury 200 OptiMax DTS
Owner's Manual
83 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mercury 200 OptiMax DTS and is the answer not in the manual?
Ask a question
Mercury 200 OptiMax DTS Specifications
General
Brand
Mercury
Model
200 OptiMax DTS
Category
Boat
Language
English
Related product manuals
Mercury DINGHY 200
36 pages
Quicksilver 200 Tendy Slatted
63 pages
Mercury Quicksilver 250 Sport
63 pages
Mercury Quicksilver 250 Air Deck
63 pages
Quicksilver 240 Tendy Slatted
63 pages
Quicksilver 240 Tendy Air Floor
63 pages
Mercury Quicksilver Series
63 pages
Mercury 300 - PRO MAX 3.0L
79 pages
Mercury Quicksilver 320 Sport
63 pages
Mercury Quicksilver 365 Sport HD
63 pages
Mercury Quicksilver 470 Sport HD
63 pages
10/15 Sea Pro/Marathon - 6/8/9.9/10/15 HP
94 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General