Mitsubishi 1998 Galant User Manual

Excessive Noise Loose pump-to-drive Tighten screws
assembly screws
Loose tube on pump assembly Tighten tube
Valves not functioning Replace valves
properly

Oil Leakage Loose end plug Tighten end plug
Bad seal crimp Remove and re-crimp
seal

MANUAL TRANSMISSION
MANUAL TRANSMISSION TROUBLE SHOOTING
NOTE: This is GENERAL information. This article is not intended
to be specific to any unique situation or individual vehicle
configuration. The purpose of this Trouble Shooting
information is to provide a list of common causes to
problem symptoms. For model-specific Trouble Shooting,
refer to SUBJECT, DIAGNOSTIC, or TESTING articles available
in the section(s) you are accessing.
MANUAL TRANSMISSION/TRANSAXLE TROUBLE SHOOTING

Condition Possible Cause

Noisy In Forward Gears .Low gear oil level,
.Loose bell housing bolts,
.Worn bearings or gears

Clunk On Deceleration
(FWD Only) .Loose engine mounts,
.Worn inboard CV joints,
.Worn differential pinion shaft,
.Side gear hub counterbore
in case worn oversize

Gear Clash When Shifting
Forward Gears .Clutch Out Of Adjustment,
.Shift linkage damaged or
out of adjustment,
.Gears or synchronizers damaged,
.Low gear oil level

Transmission Noisy When
Moving (RWD Only) Quiet In
Neutral With Clutch Engaged .Worn rear outputshaft bearing

Gear Rattle .Worn bearings,
.Wrong gear oil,
.Low gear oil,
.Worn gears

Steady Ticking At Idle
(Increases With RPM) .Broken tooth on gear

Gear Clash When Shifting
Forward Gears .Worn or broken synchronizers

Loud Whine In Reverse .Normal condition (1)


Mitsubishi 1998 Galant Specifications

General

Brand	Mitsubishi
Model	1998 Galant
Category	Automobile
Language	English