Polaris 9919510 User Manual (English)

Questions and Answers:

J
James PageJul 28, 2025
What to do if my Polaris 9919510 Offroad Vehicle engine turns over but fails to start?
- G
  Gina MartinezJul 28, 2025
  If your Polaris Offroad Vehicle engine turns over but doesn't start, several factors could be the cause. First, ensure you have fuel by turning the fuel valve to reserve and refueling if necessary. Check for a clogged fuel valve, and clean or replace it if needed. Drain the fuel system and refuel if water is present in the fuel. Make sure the fuel valve is turned on and that you're using new, recommended fuel. Inspect the spark plug for fouling or defects, replacing it if necessary, and verify the stop switch is on. Also, check the battery voltage and recharge to 12.8 VDC if low. Adjust throttle freeplay in case of throttle ETC switch malfunction. If the problem persists, it may be a mechanical failure, and you should seek assistance from your Polaris dealer.
R
rogersjessicaAug 2, 2025
Why does my Polaris 9919510 engine run irregularly, stall, or misfire?
- B
  Brian WilliamsAug 2, 2025
  Irregular engine performance in your Polaris Offroad Vehicle can stem from several causes. Start by inspecting the spark plug for fouling or defects, and clean or replace it if necessary; also check the spark plug gap or heat range and set gap to specs or replace plugs. Check all ignition connections and tighten any loose ones. Replace the fuel if water is present or if it's old, poor, or non-recommended. Inspect and clean or replace a clogged air filter. Ensure the fuel tank vent line isn't kinked or plugged. Recharge or replace the battery if the voltage is low (12.8 VDC). For worn or defective spark plug wire, electronic throttle control malfunction, or other mechanical failure, consult your Polaris dealer.
R
Ryan SullivanAug 6, 2025
How to fix an engine that doesn't turn over on my Polaris 9919510 Offroad Vehicle?
- M
  Michelle SheltonAug 6, 2025
  If your Polaris Offroad Vehicle engine doesn't turn over, begin by checking the battery connections and tightening any that are loose. Also, check the solenoid connections and tighten them if necessary. Recharge the battery to 12.8 VDC if the voltage is low. If these steps don't resolve the issue, the fuseable link may be the problem, and you should see a Polaris dealer for replacement.
C
connie52Aug 10, 2025
What to do if my Polaris 9919510 Offroad Vehicle engine stops or loses power?
- D
  David BeckerAug 11, 2025
  If your Polaris Offroad Vehicle engine stops or loses power, first ensure you have enough fuel by turning the fuel valve to reserve and refueling. Inspect and replace a kinked or plugged fuel vent line. Replace the fuel if water is present or if it's old, poor, or non-recommended. Inspect, clean and/or replace spark plugs if there was overuse of choke, or if they are fouled or defective; also, set gap to specs or replace plugs if the spark plug gap or heat range is incorrect. Check all ignition connections and tighten any loose ones. Recharge or replace the battery if the voltage is low (12.8 VDC). For worn or defective spark plug wire, consult your Polaris dealer.
K
Keith RossAug 15, 2025
Why is my Polaris 9919510 Offroad Vehicle engine backfiring?
- N
  natalie23Aug 15, 2025
  An engine backfire in your Polaris Offroad Vehicle can be attributed to several factors. Begin by inspecting the spark plugs for any signs of being weak, fouled, or defective; clean and/or replace them as needed. Ensure the spark plug gap and heat range are correct, and adjust or replace the plugs accordingly. If you're using old, poor, or non-recommended fuel, replace it with new fuel. For issues such as an incorrectly installed spark plug wire, incorrect ignition timing, or mechanical failure, it's recommended to consult your Polaris dealer.
R
Ryan MartinezAug 19, 2025
How do I stop my Polaris Offroad Vehicle engine from pinging or knocking?
- D
  david43Aug 19, 2025
  To address pinging or knocking in your Polaris Offroad Vehicle engine, start by replacing any poor quality or low octane fuel with the recommended fuel type. Also, set gap to specs or replace plugs if the spark plug gap or heat range is incorrect. If the issue persists, it may be due to incorrect ignition timing, which requires attention from your Polaris dealer.
C
Caitlyn AlvaradoAug 23, 2025
What causes my Polaris 9919510 engine to overheat and how do I fix it?
- P
  Phillip Horn DDSAug 25, 2025
  If your Polaris Offroad Vehicle engine is overheating, check for debris lodged in the screen and remove it to clean the screen. Also, inspect the radiator for any blockages; use a garden hose to flush any debris from the radiator fins. Be careful, high pressure washers can deform the radiator fins and reduce cooling efficiency.

Polaris 9919510 Specifications

General

Brand	Polaris
Model	9919510
Category	Offroad Vehicle
Language	English

Summary

Welcome to Polaris

Vehicle Identification Numbers

Record Your ATV's Identification Numbers

Instructions for recording VIN, engine serial number, and key number.

Safety Information

Safety Decals and Locations

Identifies locations of safety warning decals on the ATV.

Safe Riding Gear

Recommends essential protective clothing and gear for safe ATV operation.

Operator Safety Precautions

Outlines critical safety precautions and restrictions for operating the ATV.

Features and Controls Overview

Engine Electrical Switches

Explains the function of the start button, stop switch, and key switch.

Lights Operation

Details the headlight switch, indicator lamps, and operation of lights.

Throttle and Clutch Controls

Explains operation of throttle, electronic throttle, and clutch levers.

Braking System Components

Covers foot brake, brake lever, master cylinder, and parking brake operation.

Fuel System Controls

Explains the function and use of the fuel valve, tank, and choke.

Manual Shift Operation

Procedures for shifting gears, including reverse and deceleration.

Operation and Driving

Fuel Safety Guidelines

Critical warnings and precautions for handling gasoline safely.

Break-In Period Procedures

Procedures and cautions for the initial break-in phase of the vehicle.

Pre-Ride Inspection Checklist

Checklist of essential checks before operating the ATV.

Engine Starting Procedures

Step-by-step guide for starting the engine, both cold and warm.

Safe Driving Techniques

Covers general driving, turns, terrain, water, obstacles, and reverse operation.

Emission Control Systems

Noise Emission Control System

Notes on modifying engine components and noise level compliance.

Exhaust Emission Control System

Information on emissions control via engine design and maintenance.

Maintenance and Lubrication Guide

Periodic Maintenance Schedule

Outlines recommended maintenance intervals and services for vehicle upkeep.

Lubrication Recommendations

Details recommended oils and greases for engine and components.

Engine Oil and Filter Change

Step-by-step guide for changing engine oil and filter.

Air Filter and Cooling System

Procedures for air filter maintenance and engine cooling system checks.

Lights and Spark Plug Service

Guidance on servicing lights, replacing spark plugs, and cleaning the spark arrestor.

Battery and Tire Maintenance

Covers battery care, tire condition, and wheel installation procedures.

Adjustments and Settings

Brakes Adjustment Checks

Checks and maintenance for the brake system's proper operation.

Toe Alignment Procedure

Procedure for checking vehicle toe alignment, recommending dealer service.

Chain Tension Adjustment

Instructions for checking and adjusting the rear drive chain tension.

Suspension Settings Adjustment

How to adjust front and rear shock damping and spring preload.

Clutch Lever Freeplay Adjustment

Procedure for measuring and adjusting freeplay in the clutch lever.

Throttle Cable Freeplay Adjustment

Instructions for adjusting throttle cable freeplay, recommending dealer service.

Handlebars Position Adjustment

How to adjust handlebar position for rider preference, with warnings.

Carburetor and Idle RPM Adjustment

Adjusting idle speed and considerations for altitude/temperature changes.

Cleaning and Storage Procedures

Cleaning the ATV

Guidelines for washing and waxing the ATV, including cautions.

Storage Recommendations

Procedures for preparing the ATV for storage, including fuel stabilization and fogging.

Transporting the ATV Safely

Steps and precautions for securely transporting the vehicle.

Troubleshooting Common Issues

Engine Starting Issues

Troubleshooting for when the engine doesn't turn over or fails to start.

Engine Performance Problems

Diagnosing and resolving engine running problems like pings, backfires, stalls, or power loss.

Engine Overheating Diagnosis

Identifying and resolving causes of engine overheating.

Polaris Product Information

Vehicle Specifications

ATV Model Specifications

Technical data including weight, dimensions, capacities, and engine details.

Carburetor Jetting Chart

Recommendations for carburetor jetting based on altitude and temperature.

Warranty Information

Limited Warranty and Registration

Details of the warranty coverage, duration, and registration requirements.

Warranty Coverage and Exclusions

Explains what the warranty covers and what is excluded.

Obtaining Warranty Service

Procedures for getting warranty service and contact information.

Related product manuals

Polaris Outlaw 9921488

199 pages

Polaris Outlaw 9921811

184 pages

Polaris Predator 9920872