Polaris ATP 330 4x4 2005 User Manual

76
MAINTENANCE AND LUBRICATION
Periodic Maintenance Chart
Item Maintenance Interval
(whichever comes first)
Remarks
Hours Cale ndar Miles
(Km)
J
E
Fuel system 100 H 12 M 620 (1000) Check for leaks at tank cap,
lines, fuel valve, filter, pump,
carburetor; replace lines
every two years
J
E
Fuel filter 100 H 12 M 620 (1000) Replace yearly
"
Radiator
(if applicable)
100 H 12 M 620 (1000) Inspect; clean external
surfaces
"
Cooling hoses
(if applicable)
100 H 12 M 620 (1000) Inspect for leaks
"
Engine mounts 100 H 12 M 620 (1000) Inspect
Exhaust muffler/
pipe
100 H 12 M 620 (1000) Inspect
J
E
Spark plug 100 H 12 M 620 (1000) Inspect; replace as needed
J
E
Ignition Timing 100 H 12 M 620 (1000) Inspect
"
Wiring 100 H 12 M 620 (1000) Inspect for wear , routing,
security; apply dielectric
grease to connectors
subjected to water, mud, etc.
J
Clutches (drive
and driven)
100 H 12 M 620 (1000) Inspect; clean; replace worn
parts
J
Front wheel
bearings
100 H 12 M 1000 (1600) Inspect; replace as needed
J
Brake fluid 200 H 24 M 1240 (2000) Change every two years
Spark arrestor 300 H 36 M 1860 (3000) Clean out
E
Idle speed -- Adjust as needed
J
Toe adjustment -- Inspect periodically; adjust
when parts are replaced
"
J
Auxiliary brake -- Inspect daily; adjust as
needed
Headlight aim -- Adjust as needed
" Perform these procedures more often for vehicles subjected to severe use.
E Emission Control System Service (California)
J Have an authorized Polaris dealer perform these s ervices.

Polaris ATP 330 4x4 2005 Specifications

General

Brand	Polaris
Model	ATP 330 4x4 2005
Category	Offroad Vehicle
Language	English