TP-6811 7/16 13Section 1 Specifications
Section 1 Specifications
1.1 Introduction
The specification sheets for each generator set provide
specific generator and engine information. Refer to the
generator set specification sheet for ratings and other
data not supplied in this manual. Consult the generator
set installation manual, engine operation manual, and
engine service manual for additional specifications.
Consult the generator set nameplate for specific
generator set r atings.
1.2 Controller Specifications
The generator sets covered in this manual are equipped
with the RDC2 controller. For a specific description of
the controller, see the generator set operation manual.
Environmental Specifications RDC2 Controller
Operating temperature
-- 3 0 _ to 70_C
Storage temperature
-- 4 0 _ to 85_C
Humidity 5--95% condensing
Voltage Requirements
Controller operation 12 VDC
Built-in battery charger 120 VAC
1.3 Engine Service
Model 38RCL generator sets are equipped with 4-cycle,
six-cylinder, liquid-cooled General Motors engines.
Model 48RCL, 48RCLA, and 60RCL generator sets are
equipped with 4-cycle, eight-cylinder, liquid-cooled
General Motors engines.
For engine service information and specifications not
covered in this manual, see the engine service manuals.
See the List of Related Materials in the Introduction
section.
1.4 Engine Specifications
Selected engine specifications are shown on the
generator set specification sheets. For additional
engine specifications, refer to the engine Service
Manuals. See the List of Related Materials in the
Introduction section.
1.5 Alternator Specifications
Selected alternator specifications are shown on the
generator set specification sheets and also shown in the
table below. Consult the alternator service manual for
additional specifications. See the List of Related
Materials in the Introduction section.
Alternator Specifications
38RCL
48RCL
48RCLA
60RCL
Manufacturer Kohler
Exciter type
Brushless,
Permanent
Magnet
Brushless,
Rare-Earth
Permanent
Magnet
Brushless,
Rare-Earth
Permanent
Magnet
Alternator type:
4 leads, 120/240 VA C 4Q5 4Q7BX 4Q10X
12 leads, Reconnectable 4P5 4P7BX 4P10X
Voltage regulator Solid State, Volts/Hz
Insulation: NEMA MG1
Material Class H
Temperature rise
130_C, Standby
Bearing: quantity, type 1, Sealed
Coupling Flexible Disc
Amortisseur windings Full
Voltage regulation, no-load
to full-load
±1% RMS
Unbalanced load capability 100% of Rated Standby Current
One-step load acceptance 100% of Rating
1.6 Torque Specifications
For alternator assembly torque specifications, refer to
the alternator service manual.
For engine assembly torque specifications, refer to the
engine service manual.
See the List of Related Materials in the Introduction
section for document part numbers.
To Next Page
Loading...
Need help?
General
