To Next Page

To Previous Page

2.3 TenSioninG anD cenTerinG THe rUnninG belT

cHaPTer 2: imPorTanT SafeTy inSTrUcTionS

After placing the treadmill in the position it will be used, the belt must be checked for proper tension and centering. The belt might need to be

adjusted after the first two hours of use. Temperature, humidity, and use cause the belt to stretch at different rates. If the belt starts to slip when

a user is on it, be sure to follow the directions below.

1. Locatethetwohexheadboltsontherearofthetreadmill.Theboltsarelocatedateachendoftheframeatthebackofthetreadmill.These

bolts adjust the rear belt roller. Do not adjust until the treadmill is on. This will prevent over tightening of one side.

2. The belt should have equal distance on either side between the frame. If the belt is touching one side, do not start the treadmill. Turn the bolts

counterclockwiseapproximatelyonefullturnoneachside.Manuallycenterthebeltbypushingthebeltfromsidetosideuntilitisparallelwith

the side rails. Tighten the bolts the same amount as when the user loosened them, approximately one full turn. Inspect the belt for damage.

3. Whilewalkingonthetreadmillat3mph(~4.8kph),observethebeltposition.Ifitismovingtotheright,tightentherightboltbyturningit

clockwise 1/4 turn, and loosen the left bolt 1/4 turn. If it is moving to the left, tighten the left bolt by turning it clockwise 1/4 turn and loosen the

right 1/4 turn. Repeat Step 3 until the belt remains centered for several minutes.

4. Check the tension of the belt. The belt should be very snug. When a person walks or runs on the belt, it should not hesitate or slip. If this

occurs, tighten the belt by turning both bolts clockwise 1/4 turn. Repeat if necessary.

NOTE:Usethefrontcovertoconrmthebeltisproperlycenteredasshown.Itisnecessarytoadjustthebeltuntiltheedgeofthebeltisparallel

to the cover.

caUTion!

Donotrunfasterthan3mph(~4.8kph)whilecentering.Keepfingers,hairandclothingawayfrombeltatalltimes.