Stitches & sewing techniques 29
Rolled edge sewing
The rolled edge stitch is appropriate for lightweight fabrics such as lawn, voil, organdy, crepe, etc. The rolled edge is
achieved by adjusting the thread tension to make the fabric edge roll under the fabric while overlocking. Adjust the
WKUHDGWHQVLRQWRFKDQJHWKHGHJUHHRIUROOLQJ7RVHZDUROOHGHGJH\RXQHHGWRVHWWKHVWLWFKÀQJHUOHYHUWR56HH
SDJH
7LS)RUDEHDXWLIXOUROOHGHGJHWKUHDGWKHXSSHUORRSHUZLWKDGHFRUDWLYHWKUHDGDQGWKHQHHGOHDQGORZHUORRSHUZLWKOLJKWZHLJKW
regular thread.
1RWH0DNHDWKUHDGFKDLQDQGWHVWVHZRQDVDPSOHRI\RXUIDEULFEHIRUHVHZLQJRQ\RXUJDUPHQW+ROGWKHWKUHDGFKDLQEHIRUH
VHZLQJWRNHHSLWIURPFXUOLQJLQWRWKHVHDP
1RWH7KHPLQLPXPRYHUORFNVWLWFKZLGWKWKDWFDQEHREWDLQHGIRUUROOHGHGJLQJLVDSSUR[LPDWHO\PP
Coverstitch sewing
The coverstitch can be used for covering, binding or top-stitching necklines and for hemming the bottom of T-shirts
DQGVZHDWVXLWVHWFLQDGGLWLRQWRÁDWMRLQLQJVHDPVSODLQVHDPLQJ7KHFRYHUVWLWFKLVPRVWVXLWDEOHIRUVWUHWFK\IDEULFV
It can also be used for woven fabrics.
Machine set up
'LVHQJDJHWKHPRYDEOHXSSHUFXWWHU6HHSDJH
6HWWKHVWLWFKÀQJHUOHYHUWR56HHSDJH
• If inserted, remove needle B and needle A.
• Install needles C, D and/or E depending on desired coverstitch.
'LVHQJDJHWKHXSSHUORRSHU6HHSDJH
5HPRYHFXWWHUFRYHU$DQGLQVWDOOFRYHUVWLWFKWDEOH%VHHSDJH7KHJUDGXDWLRQVRQWKHFRYHUVWLWFKWDEOHLQGLFDWH
the distance, in cm and inches, from coverstitch middle needle. Use it as a guide when positioning the fabric edge.
• Close front cover.
Start sewing
• Raise the presser foot by lowering presser foot lift.
• Place material under the presser foot behind the needle.
• Lower the presser foot by raising the presser foot lift.
1RWH:KHQ\RXVWDUWWRVHZIURPWKHPLGGOHRIWKHIDEULFSODFHWKHIDEULFDWWKHGHVLUHGVWDUWLQJSRLQWRIVHZLQJ
Securing the coverstitch seam end
Chaining off is not possible after sewing coverstitch because it causes the seam to unravel when the looper thread
is pulled out at the end of sewing. Therefore, secure the seam end in the
following manner.
When sewing through to the edge of fabric
.QRWWKHQHHGOHWKUHDGVRUWKUHDGVWRJHWKHUÀUVWDVVKRZQRQWKH
illustration.
• Tie these threads with the looper threads.
• Cut extra threads.
When sewing is stopped halfway
• Raise the presser foot and turn the handwheel one full rotation away from
you. Pull the fabric under and behind the presser foot while securing the
WKUHDGHQGVZLWK\RXUWKXPEDQG\RXUIRUHÀQJHUWRSUHYHQWWKHVHDPIURP
unraveling.
3XOORXWWKHQHHGOHWKUHDGVRUWKUHDGVRQWKHXQGHUVLGHRIWKHIDEULF
and knot the threads in the same manner as described above.
• Cut extra threads.
Note: Normally, the seams at the start of sewing do not unravel, but it is wise to
VHFXUHWKHVHDPHQGIROORZLQJWKHVDPHVWHSVDVGHVFULEHGZKHQVHZLQJWKURXJKWRWKH
edge of the fabric.
To Next Page
Loading...
Need help?
General
