Sym HD 200 EVO User Manual

15
10. Inspection and Maintenance before Riding
(Please refer to the components location diagram for the following components.)
ROUTINE INSPECTION
Check Items
Check Key Points
Engine Oil
Is there enough engine oil?
Fuel
Is it enough? Is it Octane 90 or above
Brake
Front
Braking condition? (Brake lever free play: 10~20mm)
Rear
Braking condition? (Brake lever free play: 10~20mm)
Tires
Front
Is tire pressure normal?
(Standard: 1.75kg/cm
2
)
Rear
Is tire pressure normal?
(Standard: 2.25 kg/cm
2
for 1 person, 2.5 kg/cm
2
for 2 persons)
Steering Handle
Does the handle vibrate abnormally or is difficult to turn?
Speedometer, lights,
and rearview mirror
Is it operated properly?
Do lights come on? Can it be seen clearly from behind?
Tightness of Main Components
Are screws, nuts loosen?
Abnormal Points
Do the previous troubles still exist?
CAUTION:
! If any problems are found during routine inspections always correct them before riding the scooter. If
necessary, have the scooter inspected and repaired by an Authorized SANYANG dealer.
ENGINE OIL INSPECTION AND CHANGE
INSPECTION:
1. Use the main parking stand to support the motorcycle on a level ground, remove the dipstick after engine
stopped for 3~5 minutes. Wipe oil off the dipstick and then insert it into the guide tube again (Do not
rotate it.)
2. Remove the dipstick and check whether oil level is in between the upper and lower marks.
Add oil to upper limit if oil is under the lower limit. (Check cylinder, crankcase…etc for leakage.)
OIL CHANGE:
! Change engine oil after the first 300km, and change the
engine oil every 3,000km thereafter. Clean oil filter after
the first 300km, and clean oil filter every 6,000km.
! In order to maintain the engine’s maximum performance,
check whether the engine oil is enough every 1,000km.
Add oil to upper limit if the engine oil has been found to
be inadequate.
! Engine Oil : Use API SH, SAE 10w-40 grade or better
engine oil. Otherwise, damage will not be covered by
warranty.
※Recommended Oil: SYM Genuine EXTRA 4X OIL.
! Oil Capacity : 1.0 Liter (0.8 liters for routine change),
oil filter change: 0.8 liters.
Upper limit
Lower limit

Sym HD 200 EVO Specifications

General

Brand	Sym
Model	HD 200 EVO
Category	Scooter
Language	English