35
LUBRICATING THE TREADMILL
Items Used in this Procedure
8mm T-Handle Allen Wrench
00349000 TRUE Treadmill Lubrication
For optimal performance, TRUE recommends lubricating the
treadmill running belt and deck with TRUE lubricant every 200
miles.
To lubricate the deck and belt
1. Press the STOP key.
2. Turn the treadmill off .
3. Loosen the belt adjustment bolts in the rear end caps.
4. Lift the belt and apply the lubricant to the center of the deck.
5. Center the belt and re-tension.
See Tensioning the Running Belt for instructions.
6. Walk on the treadmill at 3 mph (5 kph) for approximately one
minute to spread the lubricant evenly through the belt and
deck.
Please contact your dealer or TRUE product support to obtain the
proper lubrication.
Lift the Running Belt to
Apply the Lubricant to
the Center of the Deck
SCHEDULING QUARTERLY PREVENTATIVE MAINTENANCE WITH A
SERVICE PROVIDER
TRUE recommends scheduling quarterly preventative maintenance with a qualifi ed service provider. Please contact your
dealer or visit www.truefi tness.com to contact a local TRUE authorized service provider.
Quarterly Preventative Maintenance
• Record time, distance, and hours from the console.
• Check error log in console.
• Check running belt and drive belt tension and tracking.
• Remove the motor cover and vacuum any debris out of the drive motor, speed sensor cage, motor control board, and
heat sink motor compartment.
• Move treadmill and vacuum underneath.
• Lubricate elevation pivot points including rear stabilizing feet and the lift motor screw.
• Lubricate running belt and deck.
• Inspect all fasteners.
• Inspect all electrical connections.
• Inspect all components for abnormal or premature wear.
!
CAUTION: Only use TRUE authorized service providers. Using non-authorized service providers could void the
TRUE Warranty.
LONG TERM STORAGE
When the treadmill is not in use for any length of time, turn it off . Make sure that the power cord is unplugged from the
power source and is positioned so that it will not become damaged or interfere with people or other equipment.
Cleaning and Storing the Chest Strap
Clean the chest strap using a sponge or soft cloth dampened in mild soap and water. Dry the surface thoroughly with a
clean towel. Store the chest strap in a place where it remains free of dust and dirt. Be sure to protect the chest strap from
extreme temperatures. Do not store it in a place that may be exposed to temperatures below 32° F (0° C).
To Next Page
Loading...
Need help?
General
