Volvo 2001 User Manual

Drain off the cooling water
and the lubricating oil from the
on engine cradle p/n 9992520 and fixture p/n 884837
. If the
engine is fresh water cooled, see
page 21 .
1 . Remove the alternator, the tensioner bracket and the
starter motor . Remove the connections
from the
electrical
distribution box from the engine and remove the box and
the
wire
harness .
2 .
Remove
the return
fuel line, the fuel pressure lines and
the inlet air silencer . Install protection capson the fuel
injection pumps and injectors
. Remove the screw holding
the lever of the decompression device
(1)
and pull out the
lever . Remove the
valvecover .
DISASSEMBLY
3 . Remove the fuel filter, the oil filter, the feed-pump, the
thermostat
housing and the exhaust elbow . Also remove
the sea-water pump with its attachment tubes .
4 . Remove the valve bridge
and lift out the push rods .
Remove the rubber rings fortheoil pipe . Remove the
cylinder
head and the
valve lifters . Put the lifters on a rack in
consecutive order, NOTE!Thecylinder head boltsare phosphatised andmustnot becleanedwitha steel brush.

Volvo 2001 Specifications

General

Brand	Volvo
Model	2001
Category	Engine
Language	English