Everbilt SFP71 User Manual

2
Table of Contents
Safety Information ..................................2
Precautions ......................................2
Warranty ..........................................3
Pre-Installation .....................................4
Before First Use ...................................4
Intended Use .....................................4
Specications ....................................4
Performance .....................................4
Electrical Specications And Dimensions ...............5
Package Contents .................................5
Installation ........................................6
Submergence .....................................6
Discharge ........................................6
Electrical Connections ..............................6
Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Checking Voltage And Phase .........................7
Incorrect Rotation .................................7
Identication Plate .................................7
Insulation Test ....................................7
Maintenance .......................................7
Routine Maintenance ...............................7
Storage .........................................8
Lubrication .......................................8
Check The Oil .....................................8
Test The Oil ......................................8
Perform A Pressure Test. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Replace The Oil ...................................9
Impeller And Volute Service ..........................9
Strainer Service ...................................9
Motor And Seal Service ............................10
Reassembly .....................................11
Power Cable Connection ...........................12
Troubleshooting ...................................12
Replacement Parts .................................15
Safety Information
SAVE THESE INSTRUCTIONS – This manual contains important
instructions that must be followed during installation, operation,
and maintenance of this pump. Also familiarize yourself with the
following safety symbols and their meanings:
DANGER: Indicates a hazard which, if not avoided, will
result in death or serious injury.
WARNING: Indicates a hazard which, if not avoided, could
result in death or serious injury.
CAUTION: Indicates a hazard which, if not avoided, could
result in minor or moderate injury.
NOTICE: Addresses practices not related to personal injury.
Carefully read and follow all safety instructions in this
manual and on the pump.
PRECAUTIONS
Read instructions carefully before attempting to install, operate,
or service this pump. Know the pump application, limitations, and
potential hazards. Protect yourself and others by observing all
safety information. Failure to comply with instructions could result
in personal injury and/or property damage! Retain instructions for
future reference.
DANGER: Do not pump hazardous materials (ammable,
caustic, etc.) unless the pump is specically designed and
designated to handle them.
DANGER: Submersible pumps are not approved for use in
swimming pools.
WARNING: All wiring should be performed by a qualied
electrician.
WARNING: Only qualied personnel should install,
operate, and repair the pump.
WARNING: Do not lift the pump by the power cord.
WARNING: Do not exceed manufacture’s
recommendation for maximum performance, as this could
cause the motor to overheat.
WARNING: Secure the pump in its operating position so
that it cannot tip over, fall, or slide.
WARNING: Keep hands and feet away from the impeller
when power is connected.
WARNING: Pumps when used as decorative fountain
pump MUST be used in a circuit protected by a Ground Fault
Circuit Interrupter.

Everbilt SFP71 Specifications

General

Brand	Everbilt
Model	SFP71
Category	Water Pump
Language	English