HUSTLER HPGH5500 User Manual

30- ENG
TROUBLE ANALYSIS AND TROUBLESHOOTING
Symptom Possible Cause Solutions
Engine cannot be
started.
Generating set switch is "OFF". Turn the switch to the "ON" position .
There is no fuel. Fill tank per instructions in this manual.
Inadequate engine oil. Check oil level. This engine is equipped with a
low oil sensor. The engine cannot be started
unless the oil level is above the prescribed
lower limit.
There's no ignition. Remove the spark plug cap. Clean any dirt
from around the plug base, and then remove
the spark plug. Install the spark plug in the
plug cap. Turn the engine switch "ON".
Grounding the electrode to any engine ground,
pull the recoil starter to see if sparks jump
across the gap. If there is no spark, replace
the plug.
Reinstall the plug and start engine according
to instructions in this manual.
Consult Customer Service if necessary.
Generator has no output
There's no ignition. Reset circuit breakers.
Inadequate cord set or extension
cords.
Check cord set or extension cords capabilities
in section Controls; Cable Size in this manual.
Consult Customer Service if necessary.
STORAGE AND TRANSPORTATION
Storage
The generator should be started at least once every two weeks and allowed to run
for at least 20 minutes. Follow the instructions below for longer term storage if the
generating set will be out of service for 2 months or more
FIRE OR EXPLOSION
Gasoline is highly flammable and extremely explosive.
Empty the fuel tank before storing or transporting the generator
1. Allow the generator to cool completely before storage.
2. Clean the generator according to the instructions in the MAINTENANCE section.
3. Drain all fuel completely from the fuel hose and carburetor to prevent gum
fromforming.
4. Turn off the fuel supply at the fuel valve.
5. Change the oil.
6. Reattach the spark plug.
7. Remove the spark plug and pour about 15ml of oil into the cylinder. Crank the
engine slowly to distribute the oil and lubricate the cylinder.
8. Store the unit in a clean, dry area out of direct sunlight.

HUSTLER HPGH5500 Specifications

General

Brand	HUSTLER
Model	HPGH5500
Category	Portable Generator
Language	English