44
9. LONG-TERM STORAGE
Pay attention to the following items for long-term storage.
1) Drain off cooling water in cold season or at the status of long-term storage.
(Mentioned action is no need if anti-freezing liquid is used.)
a. Take off side door and open radiator cover.
b. Take off drainage plug of cooling water in the frame of generator to drain out water.
c. Loosen the drainage plug at the side of cylinder and drain out the water.
[Attended operations]
It is necessary to drain off cooling water. Otherwise rest cooling water in the engine may freeze
and expand thus to damage the machine.
d. Drain out the cooling water
e. Close radiator cover, hood and drainage plug after drainage finishes.
2) Stop the engine after having run for 3 minutes. Drain out the used oil when the engine is still
hot and refill in fresh oil.
3) Drain out the rest fuel completely and clear the sediment in the fuel tank.
4) Lubricate the supporting and connecting joint of regulating system.
5) Wipe off the dirty and grease stain on the machine.
6) Remove the battery cable. Charge the battery once a month.
7) Check the generator periodically.
8) Prevent vapor or dust falling into the control box, radiator, or exhaust pipe muffler. Use a
plastic cover to cover the machine. Special notice for the outdoor generators.
9) Store the generator in ventilated place without moisture or dust.
10) If start the generator after long-time storage, please perform accord with the chapter “6.1
Preparation before running”.
Refer to the engine operation manual for usage of engine.
(2) Storage
■ It will fall off or collapse to cause an accident if placed in a wrong
position.
Pay attention to the following items if place machines or other things
on the generator:
■Make sure that engine cover is not broken, and its screws are not
loosened or missed.
■The generator set should be put on a level ground hard enough to
afford its weight.
■If put a generator set on another generator, the weight and size of
above one should be less than that of the other.
■Don't run the generator set when stacks together. Otherwise, the
above generator will fall off to cause an accident.
Wood
To Next Page
Loading...
Need help?
General
